Thanks! I was able to change my own fan motor! Glad I watched the!

@crusin73

3 жыл бұрын

Great! I hope it all turned out ok for you and you are now sitting in a nice cool RV.

@janetteduran9600

3 жыл бұрын

@@crusin73 Yes it works now! My only trouble was getting that darn plug apart! But I finally figured it out.

@paularthur8055

3 жыл бұрын

@@janetteduran9600 I had a similar problem with the plug. It actually came apart ok but after pulling out the pins for the wires coming from the motor it began to rain so I quickly buttoned up everything and waited in the house for the rain to stop. When I returned I realized in my haste I somehow ended up pulling all of the wires out of the plug and I wasn't exactly sure which wire went where back in the plug. Fortunately I have a 2nd identical unit so I removed the covers and used that plug to figure out where the wires were supposed to go in the other unit. All's well now, the unit is working like a champ again. Lesson learned, take lots of pictures before disassembling! Thanks for the video, without it, I think that little plug would have gotten the best of me.

Question: our ac works well enough. We clean it annually and filters get cleaned as needed. It seems that the ac works great in the room it is in. It no longer blows the air into the other room like it used to. I can get the other room cool, but most of the air comes from the open door. A closed door greatly decreases the cool air in the other room. Motor moves freely and spins well when unit is turned on. A neighbor tells me that the motor is stripped and therefore not spinning at full capacity. There is no weird noise when it runs. In your opinion, what do you think might be the problem of the air not blowing into other room? Do you think the motor might need replacing?

@crusin73

4 жыл бұрын

If it initially worked fine and now all of a sudden it no longer works fine, it can be a number of things. I guess my first question is do you travel or sit in one spot? If you travel, I would pull the vent covers out and check to be sure none are leaking. you can get the tin duct tape at a hardware store, if you sit, you might want to clean your condenser and evaporator. you can respond to me on my face book page. sorry for the late response, I was not notified. If you Join the group "RV Add-Ons and Modifications Group" you can reach me there

Are those evaporation coil‘s that you access from the roof… Are those the same ones that I can see from inside the RV when I take the cover off? When I look up in there it’s really dirty and I can’t clean it because it’s hard to reach. So basically can I reach what I see from inside by taking off the roof cover?

@crusin73

3 жыл бұрын

yes it is much easier to reach the evaporator and condenser from removing the cover on the roof. (on this model) just remember to seal off the air conditioner at the ceiling and all power is off.

Too much background noise (music)

Good video

@crusin73

3 жыл бұрын

Thanks for the visit

Great videos. Can you post link where you purchased the new fan motor? Also if fan and squirrel cage are intact do they need replaced? Ty

@crusin73

2 жыл бұрын

I got them on Amazon. Use the model number off your A/A unit to find proper fitting parts. I replaced the fan thinking I might break the old one during removal. If you did not, no need to replace.

I'm wanting to use the squirrel cage from the old motor but can't get it off is there any use trying to get it off or should I buy a new one tomorrow

@crusin73

3 жыл бұрын

Have you tried it the way I did it in the video? if you did and still did not work, try it again after letting some wd-40 soak in to it for a while. then if it still doesn't work, I would go ahead and buy a new one. just make sure it is the right one for your model. good luck

Has anyone tried to replace the bearings in the motor? If so where did you buy them or what are the measurements?

I have a 2015 bison horse trailer with living quarters and recently found out my ac is not working but comes on. How can you tell if it needs a new motor or compacitor? And did you order your parts from Amazon

@crusin73

2 жыл бұрын

Yes, I ordered all my parts on Amazon. I tested the capacitor and found it bad. This is how I made the call.

I just replaced my fan on my Brisk Air II, but ended up with only low speed. I thought the new motor maybe had a bad high speed winding, so I purchased another new fan and installed...still only low speed. I checked all the wiring, I even switched the high and low speed (red/black) wires, and still no high speed. What am I missing? All ideas appreciated.

@crusin73

2 жыл бұрын

If hooked to a thermostat, that would be where I would check, if not I would check the wiring and the switch on the control panel on the AC unit inside.

I got to ask where did you get the parts. I need the inside cover grill. Same unit and grill as this one. Going to get up there this weekend and clean the coils. They are bad bad. Since the cover grill broke there isn't any filter and it's gotten nasty. Thanks

@crusin73

4 жыл бұрын

I bought all my parts on Amazon. I first checked the Dometic website for approiate part numbers to ensure I got the correct parts. I don't know if you are going to be able to get any parts related to the freon side of the air conditioner, these are sealed units and may be an issue. Hope this helps.

@OttoDidactic

3 жыл бұрын

@@crusin73 the refrigerant parts shouldn't be done unless you know what you are doing. I'm an ac tech

@crusin73

3 жыл бұрын

@@OttoDidactic I totally agree. that is why if you noticed I am only working on the electrical side. this is a sealed system and should not be opened up on the refrigerant side. I am I am a ASE master certified truck tech. (retired), I might know a little about it. but thanks for sharing.

You should move your camera to where you are working so people can see what you are doing Would be very helpful. Otherwise, good info,

hey so my fan blades broke off and the brackets that hold the motor up broke aswell so now i need to replace is, if i turn it on the breaker goes off after about 10 seconds, do i need to buy capacitor also? my insurance is charging me 500$ deductible i was wondering if maybe i can do it myself for cheaper

@crusin73

Жыл бұрын

It sounds as if you had an accident. if that is the case and you busted the fan motor mounting bracket, The best fix will be to replace the A/C unit.

I have the brisk air duotherm 1, capacitor was replaced a year or 2 ago (prior to me owning the camper) and the fan doesn't come on at all, I feel a slight hum when I touch the fan but even spinning the fan does nothing. Any ideas???

@OttoDidactic

3 жыл бұрын

It's probably time to replace the fan motor and capacitor. Most of the time they're changed out together. Capacitors usually aren't very expensive. Before removing the capacitor short across all of its terminals with a rubber insulated tool like a screwdriver or lineman pliers as they are designed to store a charge that can pack a serious punch. Make sure you remove both fans from the old motor. You will probably need them on the new motor

@crusin73

3 жыл бұрын

If you aren't sure how to test the compacitor, i have a part #1 to this video that shows how I did it. If it needs replacing and if I could afford to, I would take advantage of the situation and instal a "soft start" compacitor. After checking the compacitor i would test and replace the motor if needed to.

The part with the squirrel cage fan is the evaporator

@crusin73

3 жыл бұрын

Yep,

Does the dometic brisk 2 model B59516.XXIC0 have a drip pan for condensation? Mine doesn't seem to be draining properly

@crusin73

10 ай бұрын

Check if the drain holes are clogged/plugged with debris. I don't see it as a drip pan however it does catch the condensation and drains it down the side of the roof (along rain gutter). Why do you think it is not working correctly?

@joeconter8417

10 ай бұрын

@@crusin73 when the a/c runs it leaks into the camper where our living room tip out is. About 3 ft from the a/c. I see some water coming out of the a/c and running across the roof to the cutter and above the tip out. Trying to determine if the a/c is leaking somewhere it shouldn't or if I have a leak where my tip out is.

@crusin73

10 ай бұрын

@@joeconter8417 have you tried removing the inside cover (where the filter is) and re-torqing the 4 mounting bolts? It could be that the A/C SEAL has started leaking.

@joeconter8417

10 ай бұрын

@@crusin73 I will check that, thanks for the info

How to change from Celsius to ferenheit on an Rv trail brisk air av

@crusin73

4 жыл бұрын

if you go to RV Add Ons and modifications group (FaceBook)(answer questions and agree to the few rules) post a picture of your thermostat and I may be able to help.

Where can I buy the fan and the motor replacement?

@crusin73

2 жыл бұрын

I picked up mine on Amazon. Just need all the info off your AC to insure it will fit.

On the 6 pin connector for the motor to the relay, blue wire is position 1 for the connector on the diagram. Is that a flat or circle looking straight on the male connector for proper orientation? Then position 2 is black wire. Is that a flat or circle? Position 3 is a yellow wire. Is that a flat or a circle looking on the front of the male connector? I had my wires pop out on me before I could write them down or take a picture. I need proper wire orientation for the connector. The connector was just out of view on your video so I could look at it, for proper orientation.

@crusin73

3 жыл бұрын

If you go to my Facebook page RV ad-ons and modifications @RVaddonsandmods ·I will answer your question there with a copy of what I have left of the schematic decal. so as long as your air conditioner is identical to mine, this should work for you.

@quadratactical1081

3 жыл бұрын

@@crusin73 Thank you my friend, but no need. I was able to go to a dealership and they let me on their lot and I found a same make and model. I went ahead and found the exact same AC. I pulled the plug and took pics. All working great now. Thank you for getting back to me. You have an awesome one!

@WILLbeDAMNED

11 күн бұрын

@@quadratactical1081hi guys. Y’all got that schematic? I just absent mindedly pulled mine without grabbing a pick Or post it here?

What is the correct pressure for r22 refrigerant?

@crusin73

4 жыл бұрын

These air conditioners are sealed units. I will not tamper with the Freon in a sealed unit. therefore I can only say Refer to the AC label on the unit. sorry for the late response, I am not currently being notified of comments on these videos. you may reach me by joining the facebook group "RV Add-Ons and Modifications Group".

@leorael4497

4 жыл бұрын

@@crusin73 sealed unit , but it has a quick disconnect on it

@crusin73

4 жыл бұрын

@@leorael4497 if it has a quick disconnect on it, it is no longer a sealed unit and more than likely has been tampered with. if the Freon is low, there is a leak. this is the only way to loose Freon in a sealed unit. it is sealed to meet safety regulations do to it being in the sleeping quarters. personally, i would get a new one and properly install it. this is not worth the risk or the fine. you could buy 20 air conditioners for the price of the fine. sorry I can't be of more help on that issue, good luck.

@leorael4497

4 жыл бұрын

@@crusin73 well works pretty good after I pressurized it r22 stop leak and stays cold 👍, so good to go

I have looked all around and even contacted Demotic via email since its the only way Ive found to contact them in order to find a 1/4hp dual fan 3spd 115v 1585 rpm 3.3cap motor but am unable to locate one. I tried Amazon but they don't list any motor with full detail and i don't know the manufacturer part number since i cant get a response from Demotic. i even tried eBay but can not locate this motor. any help is greatly appreciated!

@crusin73

Жыл бұрын

what is the motor for? I found the one I needed on Amazon. you need the air conditioners seriel & model number. hope this helps.

Good day sir please I need to know how to connect the switch with the tamostart

@crusin73

Жыл бұрын

The air conditioner needs a control board attached. then you can conect with a cord typicaly provided with the thermostst. on your new A/C (under the filter cover normaly.) it will give you part numbers for additional parts for additional functions your A/C will eccept. hope this helps.

Hey maybe the next time you make one of these instead of talking how about actually zooming in with your camera showing how the capacity of wired them are showing how you put the wires in the 6-pin

Is there a link to all the parts??

@crusin73

4 жыл бұрын

I did not add links. However I did get them on Amazon. I looked up the parts on Dometic website specific to my A/C.

@hammbone82

Жыл бұрын

@@crusin73 do you have a link to the dometic website that you looked the parts up on?

Please be careful with removing the old capacitor. Some store enough charge even when disconnected to cause serious bodily injury. You're supposed to short them out across the terminals for safety. Always use insulated tools when working with equipment that uses a capacitor

@crusin73

3 жыл бұрын

You would see that is exactly what I did in the other video. Thanks for sharing

@OttoDidactic

3 жыл бұрын

@@crusin73 I understand. The comment was more intended for those who don't have the knowledge base we do for their safety. Excellent instructional video sir. I look forward to watching all of your videos going forward

@crusin73

3 жыл бұрын

@@OttoDidactic Thank you.

Dial back the music volume....can barely hear your narrative! 😬

Nesecito alguien que me repare una unidad de aire acondicionado de una camper

@crusin73

Жыл бұрын

Sorry, I only speak english and did not understand what you typed.

I don’t really like to have seen this but I’ve never seen such poor camera work so I’d give this video about a three

@crusin73

3 жыл бұрын

Yep, it was a poor one. it was in the 100's that day and my camera kept overheating and shutting down. I ended up using my phone for most of this video. but as long as I was able to share the point of this video, I feel ok about it. if it has helped one person, I accomplished my mission. I am not sponsored and I am not receiving any money to do these videos yet. everything is out of my own pocket. I am a one man show, no crew or help with the filming, editing or producing. I hope what I showed was useful for you. Thank you for watching.

The music is annoying

Where can I buy the fan and the motor replacement?

@crusin73

2 жыл бұрын

I bought mine on Amazon.