33k kms and an injector failure in VW Caddy 1.6Tdi 102cv. Just outside warranty and VW have told me to take a running jump. 1100 Euros. Never again.

yes, 1.6 tdi have sensitive injectors

gorgeous volkswagen cheaTDI engine

@Danial0152

7 жыл бұрын

hahaha good one

Good cars if used correct!this means no short trips ,engine must get hot and over 100km/h daily you drive a 1 6 tdi 500 000km with normal issues ! If you drive a diesl vw alot in city 50 a 70 km/h your car get alot broken.

I would recommend changing fuel filter first, there is fuel starvation not faulty injection.. probably bad fuel

@ingeborgsjon

3 жыл бұрын

Bad injectors can lead to fuel starvation on those cylinders. It's pretty easy to check with diesel return flow equipment (costs about €40).

Had this experience today on my passat 2014 2.0 tdi. Gutted

Hello. It was 2 new injectors replaced. And after that there was no problem. I have the problem every cold start. And after a few minutes whit cold engine the engine run perfekt

Check fuel pressure sensor Then change Fuel filter every 25-30 k km Your injectors are normal Another issue to consider is to clean the throttle body

@TruthTortoise81

11 ай бұрын

The 1.6tdi engines 09-12 have bad injectors it's a very well known issue.

@webpro607

6 ай бұрын

could be a fuel pressure sensor even without an error in the ecu?

@InMoroccoholidays

6 ай бұрын

@@webpro607 or loose injectors , knocking like a helti driller

@LorisSingh

5 ай бұрын

I have the same from time to time Vw told me to clean the diesel particle filter / dpf Does that make sense

Most injectors from Volkswagen are from the brand named Magnetti Marelli. Thats why they go bad after a while. They are very cheap made from Italy. And some models uses from Bosch they last for ever.

@vladmihai306

6 жыл бұрын

This is a diesel car, so no Magnetti Marelli. These 1.6TDIs have Siemens, Continental or Bosch injectors.

@joshuagarden7304

5 жыл бұрын

However, the worst by far are the Lucas/Delphi injection systems. Total cancers. And they are everywhere.

@vladmihai306

5 жыл бұрын

Joshua Garden 1.5 dci from Renault, which is used on Nissan, Dacia and now Mercedes benz uses Delphi injection system and this engine is known as being one of the most reliable diesel engines using common rail injection. So it depends on the implementation, software that each manufacturer chooses. Also, many manufacturers have started to develop and use common rail technology from early 2000s, whereas VW bet on pumpe duse. The car in this video is their first attempt at a smaller CR engine and as you can see, it is not a great first try.

@joshuagarden7304

5 жыл бұрын

Vlad Mihai I know 1.5 Dci very well, have Clios and Kangoos with that engine in the family, friends, and in the company. In my view they are not that reliable. They are a russian roullette, some give big trouble, others not so. However most of them had injectors replaced well before 250,000 kms. They can last longer however it is very, very uncommon to see a 1.5 dci with original injectors past 300,000 Kms. In contrast a 1.4 D4d with Denso injectors is most likely going to do 300,000 with original injectors. I have a friend with a diesel injection repair house, he tells me Delphi/Lucas is by far the worst system.

@vladmihai306

5 жыл бұрын

In any case, compared to these Siemens crap that fails at 100k they are better. Sure, nothing can beat non PD engines like the venerable alh with rotary pump.

He did you fix it after replacement /tanks

Mine Skoda Octavia 1.6 does the same problem , first of all it didn't want to start , than i remove the sonda from DPF filter and the car started but took 30 min to start . Than i didn't want to believe that is injector problem because there was no error on a computer. So i changed the fuel filter and got better . Now the car starts right away but still there is a little sound and shaking the engine, once the engine gets 60 degrees there is no problem the car goes eazy with no sound nothing .. now i want to check all fuel regulation before i change the injectors ... any advice from where to start with checking the fuel regulation ?

Check, repair or replace: - injectors - the fuel pressure sensor - fuel pressure regulator i had the same problem.

@imrxnz2531

Жыл бұрын

Hi could you check ny video pls i dont know if its the fuel injector or glow plugs or something else

did you manage to get it fixed?

My vw caddy 1,6 tdi 2015 , 65.000km , probably the same problem. Just went to mechaniks and whateing for a phone call to finde out what is wrong. Im going mad and this is my secund vw. First Polo 1,2 tsi last for 47.000 km and than the bed chain cased motor damage. Car was fixed for 800 Eur and every half year 1 l oil vas missing. What to buy next? Dachia

@boboguitar

4 жыл бұрын

890EUR the 3 one gone.

Did you have blue smoke? Mine does this and has blue smoke

تشاك مهوش شاعل بصح تفيبري ودخن يقدر ايكون بروڨرام مع العلم اني نحيتهم ونضفتهم اخي

Very same with mine. So I changed all injector.

@manfredeberhardt2435

5 жыл бұрын

Hyuk hee Lee did it help ?

The funny think is that no check engine light come on

Can you please tell me if the problem was at every cold start? The engine was loss in power and noisier until getting a little bit warm? I have the same problem, but only when outside the temperature is between 10-18 °C... when it's hotter or colder starts normal

@janottossen3238

7 жыл бұрын

Gabi Amo .hello Gabi, it was every time with cold engine and its take about 1 min. before all is normal again. No lost power after that 😀

@manga1boy

7 жыл бұрын

Thank you very much for the quick response! My car does not do this at every cold start, but once a couple of days and it seems to be worrying

@manjitdhillon3831

6 жыл бұрын

Gabi Amo my revs fluctuate and car shakes when cold, also lags and stalls when slowing down, is this an injector problem? Or something else?

@busmeikeris

6 жыл бұрын

Guys I have exactly the same problem any advise?

@wendytavarea2849

6 жыл бұрын

Hi mate my still do same. But wen the temperature is 43 degrees this issue start.. I changed Camshaft, fuel filter, pump tandem, injectors, and still doing the same..

Can't believe what a crap cars are these recent vw's , will definitely stick to Toyota.

@christineayres5339

7 жыл бұрын

Modern VWs = Shit , i own a Mk4 Tdi golf and even that is rubbish sensors always failing and fuel pump is crap , best car i ever owned was a car made in France in the 90s called a Citroen ZX Turbo Diesel it looked like crap but was unbrakeable i did 340 thousand miles in it before i gave it away to a friend, i truly believe Modern cars are made to break and cost hard working people money

@matevzproje5204

6 жыл бұрын

I have 2004 mazda premacy worst car in history. All rusty engine problems all the time , but out vv golf 6 1.6 tdi running strong after 10 years and 455k kilometers.

@joshuagarden7304

5 жыл бұрын

All modern cars are overpriced, unreliable crap full of complex and expensive electronic parts. The time where cars were made to last is over. Toyota maybe a bit more reliable but is no exception.

@JMNTN

4 жыл бұрын

so what you're saying is that every toyota ever build has no problems whatsoever, my family has owned 7 vw or audis to this point and non of them had major problems, the biggest problem i encountered was a bad transmission on a 1.9 tdi a6 but that car had over 300.000 km

wow 46k and she has a faulty injector.

@nakkie1616

5 жыл бұрын

Yes they had factory fitted injectors that were bad. Siemens.

@assafjacob5762

4 жыл бұрын

@@nakkie1616 Do you know which I should buy to fix this issue? Or a link perhaps...

@garethjones8047

3 жыл бұрын

These cars are built from chocolate

Mine is same.Problem commun rail 1800 euros 🥺🥺

My 1.6tdi sounds like this for 2-3 min. and then is everything ok. ?

@r28011975

Жыл бұрын

Hay Alpo I've had the same problem for years. Can you tell me what the problem was?

Me acaba de pasar ahora mismo ma dejao tirao que problema es alguien me lo puede decir

Problème circuit gasoil , code défaut p0087

the same problem...i changed 1....but now after 1year it's other one go

@ashutoshkudav1059

5 жыл бұрын

Same here

@panedroberts4688

3 жыл бұрын

the other 1???, there are another 3

@luksurias

3 жыл бұрын

@@panedroberts4688 I changed 6 injectors (1+1 and then all 4 injectors).

Did you solve the problem, was it one bad fuel injector or all four of them were bad ?? ✌🏻

@janottossen3238

2 жыл бұрын

Hello. It was two bad injectors 😀

@kali6650

2 жыл бұрын

How much total cost thanks

@cannonshot7778

10 ай бұрын

How did you diagnose there was 2 bad injectors? @@janottossen3238

I have exactly the same car and the same problem. first i thought it's the injector and i changed it, but the problem still exists... did you find a solution?

@crisscoca2241

6 ай бұрын

Did you change all 4 injectors or just 1 ?

@webpro607

6 ай бұрын

​@@crisscoca2241 I found out that my injector is 100% fine, I check compression on this cylinder and found that it has no compression at all.. then opened the camshaft cover and found that the valve spring is broken.. still didn't fix it and i hope that piston was not damaged...

mise à jour des injecteur

Sorry, i dont remember, it´s to many yers ago i have this terriple car 🙂

Şarj marş dinamosu arızalı

@ozgurkaya4030

7 жыл бұрын

mehmet ATAY mazot puskurtemiyo farkindaysan

hay,I've had the same problem for years. Can you tell me what the problem was?Maybe you can give your gmail and i send video for golf6 81kw 2.0

l problema è noto su tutte le motorizzazioni 1.6 Tdi gruppo Audi volkswagen seat. Gli inettori lavorano con poco gasolio maggiomente a motore caldo. Valvola EGR molto invasiva e problemi sul FAP. si risolve definitivamente con intervento su centralina motore ottimizzando i parametri senza sostituire gli iniettori. guardate il mio video, testato sulla mia audi a3 1.6 Tdi 105cv. se volete risolvere contattatemi pure

@emanueledinolfo9994

6 жыл бұрын

Michele GTInero ciao mi chiamo Emanuele...io sulla mio golf 6 1.6 tdi ho tolto il fap e valvola egr....però ho gia sostituito due iniettori senza garanzia...la macchina ha solo 120km cosa potrei fare.......grazie

@danilobarone6060

4 жыл бұрын

Ciao a me tutte le mattine fa cosi come un trattore come potrei fare

@felixjaramillo6327

4 жыл бұрын

la mia fa così me un trattore alla mattina quando si accende poi si normalizza lo portata dal meccanico e mi hanno detto che tutto ok la centralina non rileva nessun problema

@gtinero5698

4 жыл бұрын

@@felixjaramillo6327 si certo che la centralina non rileva nessun errore. Ma per risolvere bisogna intervenire sulla centralina ottimizzando i parametri di gestione della iniettori. Fidati testato e garantito

@felixjaramillo6327

4 жыл бұрын

e cosa mi consiglieresti di fare allora

The worst diesel engine from VW, i had to change all four injectors in my Vw Polo 1.6 tdi because of this noise. 🤦🏻‍♂️

@janottossen3238

2 жыл бұрын

Tractor shit 😵

What did you do??

@janottossen3238

9 жыл бұрын

Hi, i replace two bad injectors

@thomasdxx

9 жыл бұрын

were they covered by warranty or did you have to pay for them?

@janottossen3238

9 жыл бұрын

I was very lucky. I got it changed on waranty one week before the waranty end. But only the two bad injectors. Vw told me if i want to replace all injectors .i have to pay for the rest . But i dont do it because it's expensive like hell in denmark :-( Do have a problem like this whit your injectors ??

@thomasdxx

9 жыл бұрын

***** not at all, 140k and not one issue at all

@MrMouldishka

9 жыл бұрын

Sorry,but what about result,i see i have same probleme :(

Does the 2 liter version also have injector problems as the 1.6 version

@marijobosnjak7259

3 жыл бұрын

No. The 2.0 81kw and 2.0 103kw/125 kw have bosch injectors! 1.6 have siemens😉

@bw26brw86

2 жыл бұрын

Does Bosch make 1.6tdi injectors by any chance??

I have passat b7 2.0 tdi. Same problem. Just first start. Later going normal. Its maybe injektors?

@desaretmurati1647

3 жыл бұрын

Pozdrav brate! Jel si popravio problem,u cemu je bilo? I meni ista muka mi je!

@ingeborgsjon

3 жыл бұрын

Could be EGR valve giving up also.

@vitezistine3133

3 жыл бұрын

@@desaretmurati1647 i kod mene...reparirao diznu jednu ali idalje se cuje ovako samo ne skace kazaljka kao ovome.

@desaretmurati1647

3 жыл бұрын

@@vitezistine3133 nisam profesionalac,ali kazu da odjednom treba da sve dizne reparirati i kodirati,tako su meni uradili,i zasada bez problema!

@vitezistine3133

3 жыл бұрын

@@desaretmurati1647 jest s tim sto bi me to izaslo 1000km i vise...izgleda da ceme to docekati.

Injectors are made by Siemens not VW.... The 1.6 cr engine itself is a good one but the Siemens high pressure system is faulty. This engine with replaced injectors is nice, or the later version with Bosch hp system is also good.. can run 500k kms or more.

@newt9493

3 жыл бұрын

2012 caddy 1.6tdi - all injectors replaced.. interested in the knowledge behind this but think you may of got brands mixed up.. as far as im aware it is the bosch unit that is faulty, although if there is a Siemens one out there that works, I would like to know for obvious financial reasons lol

@vitezistine3133

3 жыл бұрын

From which year they starting to use bosch injectors in golf?

@bw26brw86

2 жыл бұрын

Hello which replaced injectors is good??

A real tractor, 46000km and already broke German cars

@JMNTN

7 жыл бұрын

Mine has 117k km and never had any problems, it's just luck, any car model has it's common problem

@pejalp

7 жыл бұрын

mine has 186k hahahahha

@tomjardine100

7 жыл бұрын

Elcactouss06 All VW engines sound like tractors. Other cars are smooth and refined

What did you do i have now the same problem...

@janottossen3238

8 жыл бұрын

+Giwta Lyxnakh hello, i change two bad injectors and sold the car after this . i have also change gearbox and turbo , the car was only two years

@TheRandomShit792

8 жыл бұрын

+Jan Ottossen how much did you pay for that job? (injectors replacement)

@janottossen3238

8 жыл бұрын

Nothing .It was under the garantere. But I know it is very expensive in denmark

@DimitrisTheodopoulos

7 жыл бұрын

turbo and gearbox for only 2 year old car? just like that?

@janottossen3238

7 жыл бұрын

yes. never vw again ;-)

Pozdrav, malo je danas majstora koji bez dijagnostike mogu utvrditi kvar. Problem je kad dijagnostika nista ne pokaze. Moje auto ( VW Sportsvan 1,6 TDI od 2014 ) je bilo po radionicama i niko nezna rijesiti problem. Naime, ujutro kad hladnog upalis motor se drma i trese kao da radi na dva klipa. Dodavanjem gasa i kretanjem motor trza i pojavljuje se zvuk slican zvecarki. Nakon 2 do 3 min nema vise trzanja, auto se normalno ponasa. Promijenjena pumpa goriva. Zelio sam da Vas pitam: Mogu li ovakve siptome uzrokovati dizne ili nesto drugo? Hvala 1

@r28011975

Жыл бұрын

Jeste uspjeli popravit

@kenankundo7380

Жыл бұрын

Meni trenutno izbaca check engine, grijace koji trepte, motor mi se trese, ispod mjenjaca nesto pucka i zvecka, ugasi mi kompjuter turbinu, motor mi se trese ko lud i vuče 0. Pretpostavljam da su dizne, međutim sumnjam i na klapnu gasa, pumpu goriva itd…?

@TheDJharry

Жыл бұрын

@@kenankundo7380 dizna je u pitanju. Provjeri sve 4 preko Dijagnostike da vidiš koja koliko baca goriva i vidjet ćeš da je problem kod njih. Imao sam taj problem kod 2.0 TDI Audi a3 na 290.000km Stavio polovnu diznu i vozio do 389.000 bez ikakvi problema. Prodao Ga i lik još uvijek vozi auto kaže nema nikakvog kvara još na njemu 😂

Mine aswell! 46k 2012 vw scandal pure shit vehicles!!!

Da taj golf nije sad kod mene, isto tako radi

salut j'ai le même problème

@flocash4305

6 жыл бұрын

Salut sami as-tu trouvé ton problème moteur? Moi j'ai le même problème sauf quand je met la clim où les feux où le dégivrage arrière la voiture tourne correctement

@Nonomimi.

5 жыл бұрын

Problème des injecteurs j'ai la même problème Il ça coûte 610 euro par un

Tractor ...... shit ....:-)

Golf working like a man truck ... injektor devil problem

Problem with injectors, should to do calibration edhe Servis all injectors. This one of the reason why we should not drive vw. Stupid car. Japanise car is better!

Diffetto molto diffuso su queste auto di pessima qualità! Si rompe pompa è iniettori. Mio cugino stesso pronlema! Oltre che a rotto il cambio! Qualità tedesca di merda!

@OwNoK

5 жыл бұрын

Gianni Lamberti sempre meglio delle alfa romeo

@nicomuffbass

3 жыл бұрын

Sul 1.6 di tuo cugino si è rotta la pompa di alta pressione?