Honda Civic 2001-2005 Gas Door Won't Open
Автокөліктер мен көлік құралдары
Save money and time. Don't replace the cable or the assembly just use this repair kit .
Here are some of the tools that jimthecarguy uses
www.amazon.com/shop/jimthecarguy
Here is the link to get the parts from Amazon amzn.to/2J9HF03
Due to factors beyond the control of jimthecarguy, it cannot guarantee against unauthorized modifications of this information,. jimthecarguy assumes no liability for property damage or injury incurred as a result of any of the information contained in this video. jimthecarguy recommends safe practices when working with power tools, automotive lifts, lifting tools, jack stands, electrical equipment, chemicals, or any other tools or equipment seen or implied in this video. Due to factors beyond the control of jimthecarguy, no information contained in this video shall create any express or implied warranty or guarantee of any particular result. Any injury, damage or loss that may result from improper use of these tools, equipment, or the information contained in this video is the sole responsibility of the user and not jimthecarguy.
Пікірлер: 71
Thank you so much for this video!!! I was stranded at a gas station 4 hours from home without gas because my gas door wouldn't open. Because of your video I was able to get access to that cable and pop the gas tank door so I could come home last night. I held the cable together and pushed down on the lever and presto. Today I'm going to get that kit that you talk about so I can actually fix it. I don't know how to thank you enough. I am going to like and subscribe and share with all my friends.
My 2006 had this problem. I could open the trunk but pushing to open the fuel door would not work. The fuel door can be opened by pulling the cable from the trunk in a pinch. I replaced the entire cable. A new cable is not expensive from Honda, only about $30. My dealer, however, claimed it was a $600 job because they have to "tear the whole car apart". The procedure is fairly simple and clearly documented in the service manual for anyone wanting to diy.
@jimthecarguy
3 жыл бұрын
Yes that job is easy but it does take a lot of time
@enesertt_
2 жыл бұрын
@Jim Trainor can you please define the exact location of opening the gas door from trunk? I cannot find it :(
@jptrainor
2 жыл бұрын
@@enesertt_ You have to pull on the truck latch cable. Pulling from the trunk end has the same effect as pushing the handle in the cabin to release the fuel door. You'll need a tool or a small length rope to do it. I had an small length of rope attached to mine for months before I finally replaced the cable.
@jptrainor
2 жыл бұрын
@@enesertt_ Pull on it right where the cable engaged with the trunk latch mechanism. It should be easily visible and accessible.
Dorman gets it right every once in a while. Nice fix Jim!
@jimthecarguy
3 жыл бұрын
Hahaha Every once in a while they do get it right.
Nice one. I was stuck at a pump to fill up the other day, and I had to get a passing stranger to wiggle the cap with a knife while I pushed the lever. Two man job 🤣
Worked for me in 2023. Ordered the piece. Followed the directions exactly as in the vid. Worked the first time. Thanks.
Thank you for your help! What a lifesaver. This problem came up in the middle of a road trip!
Hi there, Thanks to your video I was able to fix my neighbors daughter. It was exactly the same problem. Great video! You rock!
Very thorough in his Presentation covers everything problem tools solution step by step fix w part #,thumbs up to this Gentleman. 👍
Really helpful! Thought I was going to have to pull out all the carpets etc.!
Had this happen. Used tubing from Lowe's (think it was hard plastic water line for a refredgerator) and cut slots in either end and metal pin retainer clips to hold the cable in place inside the tube. Works great.
@jimthecarguy
3 жыл бұрын
Good repair.
Thank you for your time! Appreciate the information
My 2003 Taurus has an ingenious gas cap door - You stick your finder under the gas cap door and pull it towards you and it opens - no cables, not switches, etc.. Foolproof
@jptrainor
3 жыл бұрын
Where I live I see Civics driving around with gas door slightly ajar. The owners don't latch it shut so that they too can use the reliable old fashion method.
@jimpie231
3 жыл бұрын
Locking doors came about after the 1974 gas crisis. Gas was hard to get and people were siphoning (stealing) gas out of cars. In my family there were many Honda’s including a 92, 96, 97, 98, 02, 06 and none of these had this problem. Each of these went well over 150,000 miles. Only problem was the hood latch (on the 98, sold this one with 170,000, it was a stick, & sold it for health problems ), plastic broke & I used a pair of pliers to open the hood. I currently have a 2009 CRV with 118,000miles and no such problems.
@jimthecarguy
3 жыл бұрын
Thanks for your input and for watching.
@jimpie231
3 жыл бұрын
@@jimthecarguy Keep up the good work, I enjoy your videos.....thanks.....Jim
Thank you for your efforts. The video was clear to understand up til the point you came back with the new part. After the camera angle was hard to see what actually you did... Hope I can get this issue to resolve...
Thank you so much. I was in a bind and needed to be able to access the cable so I could open the cover and not run out of fuel!
Ordered my part. Will do the work when it arrives. Thanks
Nice fix Jim. I replaced the hood cable on my 2000 Honda but not gas. I now know the quick way if I have to change it!
@jimthecarguy
3 жыл бұрын
Thanks for stopping by Mike.
Nothing like a good ole YT tutorial that starts out by saying you won’t need much but a screwdriver then proceeds halfway though to tell you to order a starter KIT and MORE tools… after you’ve tore off half the door
I like the Peter Finn version, specially the final option of screw driver & crowbar.
Great video. Thanks. We just bought a used Toyota that has this problem. Off to the parts store.
tank you for the good advise
Always very instructional.
@jimthecarguy
3 жыл бұрын
Thanks for topping by
I have a 2003 Honda Civic Coupe two door, is the removal of the panel behind the drivers seat the same as the four door you just demonstrated? Thanks in advance
Thank you!!
Hi Jim, had this happen at the gas station this morning. My metal piece is actually still attached to the white plastic. All go there, but the black sheathing has pulled loose from the metal clip. Will the Dorman kit work for me? Had you seen any break in this fashion? What might be my repair solutions? In the interum, how do I get the fuel door open to fill the gas to get to work? Is there an emergency area to pull in the trunk somewhere?
Good Job Jim
@jimthecarguy
3 жыл бұрын
Thanks for watching.
I am having this issue on hte 2009 Accord coupe. Is it possibly the same issue at the lever or did Honda upgrade it by 09?
For a quick fix use jb well the one that looks like clay, comes in a tube . That shit has help me in multiple occasions
@jimthecarguy
2 жыл бұрын
Thanks for watching and your input.
Those cable bracket clips always break due to the massive amount of VTECH horsepower. Haha Nice fix Jim, stay safe.
@jimthecarguy
3 жыл бұрын
Thats for sure all that torque will do it.. Thanks for stopping by .I hope all is well
Hi Jim I have a question would that dorman part you put on that Honda civic in your video will the same part work on a 2000 Honda Accord ex I'm having the same issues my trunk will open but my gas door won't open and if the part does work could you write me the dorman part number down because I've been trying to rewind the video but I can't see the part number on it very good
The world is so much better because you exist 😇
Jimmy! I can't afford a repair kit 😞 Do you have a more ghetto approach to this problem?
Thanks for saying you only need a couple tools then mentioning a repair kit near the end.
Thanks
For the door sill. Any name for the clips
Would this fit an Acura tsx?
Will this fit 06 civic??? Please help.
Is this the same for 2007?
Will this work on a 2006 Honda Civic?I just seen this exact part on Amazon.
@erasmososa6861
2 жыл бұрын
I'm also looking the repair kit for my 2007 Honda Civic but haven't been able to find that part for that gen. have you ?
@amaliaortiz8540
2 жыл бұрын
@@erasmososa6861 no I haven’t :(
Same problem I have with a 2009 Honda Accord but only the trunk won't open.
Take this ovahhhh hea, now this ova hea and make sure it's hea. Just incase you don't remember, take this ova hea not ovah der
Jim - I have a 2010 Maxima. When I start it in the morning, it makes a noise - gruh, gruh, gruh, gruh, gruh. When I back out of the driveway, it makes the same noise a few times - gruh, gruh, gruh. It does not happen the rest of the day, even if the car sat for 4 - 5 hours. The sound seems to be coming from under the hood, seems like by the firewall? Do you know what it might be? No idiot lights are on and everything works in the car. Thanks.
@jimthecarguy
3 жыл бұрын
Can you send me a short video of the noise?
@billlink7116
3 жыл бұрын
Will do Jim. I'll try to catch it tomorrow AM.
@billlink7116
3 жыл бұрын
Now it seems to also have a sound when I turn the steering wheel to the left, moving or not. Sounds sort of like a grown. I'll try to capture that sound as well, on a separate recording. Thanks for your help. Stay well.
@billlink7116
3 жыл бұрын
Jimthecarguy - Why is it that symptoms go away when you're trying to share them with someone? I took my tablet into the car to capture the sound two days in a row and you guessed it - nothing. The next three days, I forgot the tablet and you guessed it again - made the noise each of the three days. What's up with that? I'll try again to capture the sound.
yea because i’m carrying tools with me every where , thanks
I broke it even more lol
You need help with shooting your videos. This was a great idea for a video but not captured very well.
@jimthecarguy
3 жыл бұрын
Thanks for watching anyway.
@TractorWrangler01
3 жыл бұрын
@@jimthecarguy l'm not trying to be mean. Just constructive. I still like your content. ☺
@Jay-zx7fs
Жыл бұрын
@@jimthecarguy It was not bad at all. Clearer than most Ive seen. I appreciate it!
I bought the overpriced kit and it didn't work. The cable still slid through the clip. Save yourself some money and do the gear clamp repair.
Can't see shit what's he doing