Not to bad of an install thanks

With those connectors with the unsealed backs, you can fill them up with dialectic grease it’ll keep the water out

Great job team!

@CartPerformance

2 ай бұрын

Glad you liked it!

1998-99 club car DS 48-volt lithium conversion - What wiring must remain, such as the Wiper Switch Assembly, . . removed onboard computer, right? but that is a little confusing when some vital components are needed.. . . etc? so what would regulate voltage for speed?

I have one blue wire coming from the front which I am guessing is the key switch. Does this just go to the positive on the converter? I am using a fuse panel so what size fuse should I put for that one? As well should I use a 20amp fuse for the headlights?

@CartPerformance

8 ай бұрын

Yes the blue wire is most likely key switch power. You hook the convertor key switch wire to the blue wire. 20 amp fuse will be plenty. The convertor is already fused at the 48 and 12 volt power source.

So I get the principle of the bypass of the OBC, but on my 2001, I have a 3 prong connector coming from my OBC, with yellow, red and brown wire, but no blue and white wire. I've scoured the internet looking for a how to bypass this type of OBC plug, to no avail. Please help!!

@gatorson

3 ай бұрын

You have a series cart. For the Series carts You just have to disconnect the Yellow wire from the OBC and run it directly from Solenoid to controller B- (or other negative source like pack negative).

From a range perspective that 72AH should be similar to a conventional 48V pack discharging to 50%

@CartPerformance

Жыл бұрын

Yes i would say that is accurate.

Wonder if the additional mph due to the decreased weight and added acceleration due to full charged power unit?

@CartPerformance

Жыл бұрын

With the same controller we gained 3MPH! Also got there much faster. You sir are correct! The swap saves about 300lbs/150kg Kit is available in description!

@tsrwakemaster

Жыл бұрын

I think the extra speed is due to the LIPO battery holding a higher voltage under load.

Do you think the 75 amp hour would be a good choice with upgraded motor and controller on a DS series?

@CartPerformance

2 ай бұрын

No. We suggest you use a 105 amp hr.

Hi! I dig those headlights do you perhaps have a link?

@CartPerformance

Жыл бұрын

They are some of the best looking lights for ds! Here is link for them. cartperformanceparts.com/product/nokins-deluxe-plus-led-light-kit-fit-club-car-ds-1993-up-gas-and-electric-golf-cart/

Can you re-purpose the original 12 volt converter ?

@user-iy1ld7pv8c

9 ай бұрын

yes you can.

I understand the main ground wire that runs thru the OBC needs to be cut and put in the negative. But what do I with the other black wire. Also do I connect the blue and white wire together?

@CartPerformance

8 ай бұрын

Unless you have a obc bypass. You do not remove the obc. You can cut the main negative to gain more length if needed. We found out most of the club ds's will not run when you removed the obc completely unless you have a obc bypass. The harness still needs to be connected on the obc for the cart to function properly.

@jasoncrawford1513

7 ай бұрын

@@CartPerformance So, how do you bypass the OBC on a DS? Just jump the blue and white? I've seen that's only on the Precedent and that the DS you need to run the yellow to the negative terminal...although that method seems to only be when you're keeping the CC charging port. I'm using an Eco Battery with the OB charger, reducer and 51v 72ah. Can I just jump the blue and white on this model? 03, I believe with the black Sepex motor.

@leonelm.hormaza8576

5 ай бұрын

@@jasoncrawford1513 Hey Jason, did you figure it out? Im in the same boat as you.

@intranzsinger

4 ай бұрын

@@leonelm.hormaza8576 I'm also having this problem. I removed my OCB completely, did the blue/white bypass with a jumper, I hear the "click" but I'm getting no movement from the cart. Solenoid test was good.

@leonelm.hormaza8576

4 ай бұрын

@@intranzsinger I reinstalled the OBC, luckily didn't cut too many wires to remove it. I followed another video by Fenertainment or Fentertainment here on YT. He did not bypass the OBC. My cart moves now. Haven't done a test drive as I'm still working on the restoration. But it moved back and forth in the garage.

Did you actually get this cart running after you removed the OBC? If so, how?

@ericjohnson5095

29 күн бұрын

I agree with you. Converted my to lithium and could not delete on board computer. If I turn the battery off and then on, I have to touch the gray wire to the positive post for a few seconds. The battery light comes on and goes off when you remove it. Now my golf cart works. Nobody properly shows how to delete it. I tried this version of unplugging the OBC (without removing it) and my cart would not move. Plugged the OBC back in and touched gray wire to positive post (with key off) and it works. Thinking about installing a switch or push button for the Grey wire to positive post. I tried hooking up the gray wire to positive post, didn't work. Only needs a few seconds of voltage to reset OBC.

How many Ah is the gen 2 I couldn't see? whats this install cost? Thanks for the video guys!

@CartPerformance

Жыл бұрын

Amp hours are still the same in the gen 2 battery. 72ah, 105ah, 144ah, 210ah. Install cost depends on cart. Thanks for watching!

How do you bypass the obc?

@jasoncrawford1513

7 ай бұрын

For real man...No one seems to really touch on this for the DS. Some say just jump the blue and white, but I've heard that's only on Precedent models. Or, you need to run the yellow to the negative terminal. Ridiculous, that Eco Battery(my brand) and others don't address this and risk destroying a 2k battery. None of the videos seem to really address the DS for this either. Only the Precedent. Let me know if you found a work around. Just got mine. Thanks!

Now you have room for Subwoofers on each side

@CartPerformance

Жыл бұрын

Good idea! Do you have any recommendations on a sub that is weather proof?

@bradleymincey6905

Жыл бұрын

​@Cart Performance addictive audio. They put a coating on them that makes them weather proof. We ran them in several of our boats. They even male 6x9 subwoofers! The speakers have awesome sound!

Where can I get the obvious bypass?

@CartPerformance

Жыл бұрын

Send me a email bmcgolfcarts@gmail.com We can send you one.

where do they sell them?

@CartPerformance

Жыл бұрын

the kit?