This is perfect timing, I'm having this problem right now!

@FloridaVanMan

2 ай бұрын

We all are. LOL ! It is a constant struggle with these vans,, keeping the contacts clean and mechanisms lubricated.

Easy way to clean the contacts on the door switches - Cut off a pencil , chuck it in a cordless drill , use the spinning eraser to polish the contacts and pins…..

Thanks, having this problem now! This is a big help.

A CR2025 cell is 2.5mm thick the 25=2.5mm while a 2032 is 3.2mm thick 32 meaning 3.2mm, the 20 is outside diameter 20mm for both. DeoxIT is a contact cleaner many techs use, expensive but good it removes oxidation & seals, comes in stray but I like the needle dropper DeoxIT D100L a drop rubbed with a Qtip works great

My 2004 2500 Sprinter has the exact problem.. I thank you for this vid.. I knew about cleaning contacts but that dam lock button on dash I could never figure out so again ty for teaching this old fool how to play lockem up fun. UPDATE: Sanded all contacts works awesome.. Broke off slider door pull handle a week ago cause the latch would get stuck and I forced opened and snapped it .. The after market handles are pretty much factory but I noticed the seals are not that good.. These handles break all the time so i have a few new ones just in case in garage. My slider works awesome now like new. Them van wall slider contacts are tough to get sanded out but I took one for the team getn er dun.

@sergeyatlanta

2 ай бұрын

Each latch also has a micro switch on the side of mechanism. Take the mechanism out (the one that wouldn’t lock the van from inside handle) and clean/lube, make sure micro switch clicks when locked.

Great stuff.

Thanks, my passenger door usually the problem lock. All you really do, is take the door panel off and lube?

@FloridaVanMan

2 ай бұрын

The motor might be getting weak with age, but start with lube. If it only twitches the door handle when everything is lubed well, then replace the drive motor.

Have you ever seen the rear door lock when it should unlock, an unlock when it should lock? I also have the flashing passenger side light I can’t seem to be able to fix. Cleaned all the contacts and nothing.

@FloridaVanMan

10 күн бұрын

Yes! The contacts in your door jam have been turned upside down or the wires to them got swapped. Most likely the contact plate fell out of the van wall and someone put it back in upside down.

@frankgubello1014

9 күн бұрын

@@FloridaVanMan you are amazing! I’ve been messing with that for years and now it works!

Epic I had this once with my drivers door and then I opened it up and all my wires had broken within my door in the rubber tube. Was bizarre but I guess they were old. What do I do if my center console button doesn’t work at all? Looks dead like no power or something I haven’t explored it yet I just know it doesn’t work. What would you check first?

@FloridaVanMan

2 ай бұрын

We have seen two dead switches, fixed by replacing the switch. Can test with Ohm meter.

My central locking has the same issue, really good to find out it is just another common problem with sprinters, like rust around the windscreen. I really like this channel as it is specifically sprinters and I am grateful for your expertise and knowledge, it has helped me in getting to know and familiarize myself with my own 2006 T1N. Thanks!

I have so much problem with the sliding that I just close and disconnect the wire loom inside the door. After months I’m having problems again that even double locking locks all door except passenger and I have checked every thing. Also have gone through two broken brass keys.

@FloridaVanMan

2 ай бұрын

This eBay seller has good steel key blanks. www.ebay.com/usr/sevastopol-423?_trksid=p2047675.m3561.l2559

@Simonofcalifornia

2 ай бұрын

@@FloridaVanMan thanks, specially for all the videos!

My T1N didnt come with a key fob...was from an auction...so how would I know if it possibly had one or keyless entry option on my van?

@FloridaVanMan

26 күн бұрын

If your van ever had a fob there will be an electric lock button on the dash and pushing one door handle in to lock the door should cause all doors to lock. Without those symptoms, your van doesn't have electric locks.

Howdy Florida Van Man and everyone else! I've got a 2005 T1N dodge sprinter 2500 and it has that lock unlock, lock unlock lock symptom. With mine the passenger door and passenger side sliding door wont lock when I try and lock the van using the fob or central locking button on the dash. I have to physically unlock and lock them with a key or from inside the cab. I tried all the methods in your video inlcuding thorouhgly cleaning all of the contacts, do you have any other recommendations for me to try? Not sure if this is helpful at all but the inside door panel for the passenger sliding door is a wood panel so the previous owner definitely replaced the original cloth/vinyl panel, this is a passenger style van.

@FloridaVanMan

8 күн бұрын

If everything is lubricated and the door handle twitches but doesn't lock/unlock, the locking drive motor is likely tired and needs replaced.

@captainsunchipz2521

7 күн бұрын

@@FloridaVanMan Thanks for the prompt response! No twitching or noise coming from them when i hit the lock or unlock button. I guess I should look into door lock actuator switch then yes?