I have the same exact problem.99 sterling detroit 60 what part # is that valve and where did you purchase the valve thank you.

Good clip Buck, safe travels !!!

@OutBackTruckerBucky

7 жыл бұрын

Roger 10.04

Disconect the air line that goes to the fan clutch,turn the key on.If no air comes out disconect the fan solenoid wires and test the voltage.It should be 12 volts.If there is not 12 volts,the solenoid ground or ecm could be the problem.If there is 12 volts coming to the solenoid and no air coming out of the fan clutch air hose with the key on the solenoid is bad.

@bigtexan3188

4 жыл бұрын

Hey ally I have a Freightliner Columbia 05 that the fan won't stop running. Even when I turn off the a.c. it stills keep running. Water temp is always at 175 and outside temperature is not that hot to be spinning all the time. I replaced the solenoid w a new one $100 at Freightliner and did the disconnect on the air line and air Does blow out from the solenoid. What would b the next step. Need help. THANKS

@omarkh5930

4 жыл бұрын

My truck 2011 frieghtliner cascadia the same problem even the ac off still the fan spin faster and loud I changed the solenoid and the fan clutch but still the same? What is the next step

@johncalvo1743

3 ай бұрын

@@bigtexan3188 So what was the problem? Was it the high pressure switch in the a/c line or was the fan clutch bad?

@johncalvo1743

3 ай бұрын

What if air IS coming into the fan clutch on that line?

Changed mine out in my cascadia yesterday

My question is what if the fan doesn't come on at a certain temperature. Can it also be the vale that's the issue, if everything else that was mentioned does work?

Would my fan constantly being on cause my temp to be 130-150? Seems to me it whould still be higher than that because i know alot of peope put a bolt in theirs to keep it constantly running

after you replace the solenoid did you test ? was the fan free ? can you please tell me what happened! I'm having the same issue with my S60 Century, thanks in advance

@OutBackTruckerBucky

7 жыл бұрын

S60 century is a car,this video is about a Detroit engine

@MR_UNOoo

5 жыл бұрын

@@OutBackTruckerBucky an s60 is a series 60 Detroit 😤😤😤😤😂😂😂😂

@vintagesavoiur

5 жыл бұрын

@@OutBackTruckerBucky series 60

@asmoov

2 жыл бұрын

Same here

If it air leak coming from the fan when tue key its on position I hear air leak But the fan works What you think

The only way to test the solenoid is to get the engine warm enough to get the solenoid to cut off air supply to engage fan or trick the computer to trip the solenoid

Hey , You can help me understand the principle of operation of the electromagnetic valve system. thank you

Yesterday I was driving home, too, turned on, fan clutch and started working. I thought maybe the solenoid needs to be replaced. I changed a new one. but still on I came home. And was about change clutch But then I started to rummage, the wiring found frayed under starter and it was all a problem. started working properly.

@frankdavis253

4 ай бұрын

Where exactly did you find the wire I'm having a similar problem?

I rebuild my fan clutch last year and just last week replaced that solenoid but my fan still comes on alot more than what seems normal, so maybe the it could be the relay?

@omarkh5930

4 жыл бұрын

JavyT30500 mine is the same I replaced fan clutch,fan clutch solenoid,thermostat,AC high pressure switch but still the same Mine is Freightliner cascadia 2011 don’t know what else to do?

@InNoTime3377

4 жыл бұрын

@@omarkh5930 It actually ended up being the solenoid again, i replaced it and now its operating normal.

Change your fuel/water separator filter

I feel like my fun starts too late, the temperature almost gets the red when start

What happens if the fan is working well, but at the time of paying the truck, there is loss of air?

@ReptoOwnsYou

4 жыл бұрын

Bad seals in clutch fan

would this issue be the same for Mack truck?

@jasonm230

5 жыл бұрын

Jason Voorhees possibly but Mac also use vmac electric temp sensor as well.

@Matt-kg3ge

4 жыл бұрын

It is the motor not the truck

Maybe the ecm battery leaked out acid n detroyed the ecm ground common problem

Lol !!! I thought you knew about S60 Detroit Diesel engines on a Freightliner Century because that's what I'm talking about, and no is not a car

@OutBackTruckerBucky

7 жыл бұрын

Just want to make sure we are in the same page.

@shortthrow50

6 жыл бұрын

you did say " S60 Century". that would be a car buddy just fyi. Next time just say Detroit 60 freightshaker

I have Columbia 2006 with Detroit 60 and engine fan stays on should I change the solenoid valve ? Let me know thanks

@OutBackTruckerBucky

6 жыл бұрын

Dose your air go down? if not, try changing the solenoid first it is very easy and it dose not cost much

@happyg62

6 жыл бұрын

OutBackTrucker Buck no no air is fine in both tanks just the fan is not stopping even its not free when engine is off

@mbrouder

5 жыл бұрын

I have the same problem with a Mercedes Columbia. Fan is always on and loud as hell.

Hi. i have a 2013 international 7400, im having a high temperature problem due to the low speed setting on the clutch fan is not working, the fan will engage at high speed for about 4-5 seconds when the engine heats up to 230 Degrees fahrenheit. i need some help to solve this low speed fan problem,,,thanks

I was told computer was not giving the command i I paid $3000 to change the computer

@asmoov

2 жыл бұрын

I did too and it still on

I changed the solenoid but still same problem

@mrcharming6549

4 жыл бұрын

Thermostat Bro

@Me-ym6ji

Жыл бұрын

What do you mean? The outside air temperature sensor?

looks old then that

this guy is really poor at describing the facts. Very boring and confusing. No help at all