2016 Ford Focus dies after getting gas (Fix)
Тәжірибелік нұсқаулар және стиль
You can support Ukraine financially in war against Nazi Russia through these trusted foundations:
United 24 u24.gov.ua/
Serhiy Prytula Charity Foundation
prytulafoundation.org/en
Become a member to get exclusive access to perks!
/ @vasylgladun
If your car dies every time you're fuel it maybe this will help you. Fairly easy and not expensive repair
Evaporative Control System
Problems occur when your fuel tank is overfilled and/or gas flows into the EVAP line. A defective refuel and/or fuel cutoff valve prevents fuel from flowing and the refuel valve triggers the gas pump to stop, causing the car to stall.
#evaporatorpurgevalve #purgevalve #diesafterfueling #stallsaterfueling #tryityourself #doityourself
Пікірлер: 85
Thank you so much!! My car was dying after filling and then today it was happening on the highway! I had to end an Uber ride early because it kept happening. Stopped at auto zone and replaced it with your help! Much appreciated
I just had to do this on my 2018 Focus ST three weeks ago. It was a little harder to do and a longer part. I felt like removing my intake to get more space was the best instant thinking I've had in a good while. Had the old one off in 3 minutes and the new one on with intake reinstalled in another 3 min. That would be the only thing I'd recommend to you and the viewers. Great vid!
Thank you! I did it in about 15 minutes. My car had stalled twice in the middle of the road , very dangerous car. 2014 Fukus 😬
@VasylGladun
Жыл бұрын
Problem with most newer cars they are getting over engineered more with each new year model.
It's a hell of a lot easier than this video makes it look. Just remove the rubber intake elbow on the throttle body to the filter box. You'll have plenty of room to get to the end of the hose.
Thanks for the vid, you and one other person showed how to remove unlike the others. Keep up the great work
@VasylGladun
Жыл бұрын
Thank you.
I have a 2017 ford focus titanium with same problem, this video helped me fix it thanks!
@VasylGladun
2 жыл бұрын
You are welcome
@luissrangel390
2 жыл бұрын
I have the same problem I fill it up until the nozzle clicks meaning it’s full then I start it up then it just violently vibrates and shakes and hesitant to start up then it shuts off unless I press down on the gas to give it power and it works fine
Thank you so much!!! It fixed my girlfriends lemon car problem🙏🙏🙏
@VasylGladun
2 жыл бұрын
You are welcome
I had the same problem with my 2015 Ford Transit 250 a few years ago, and it had come to a point when I had to leave the engine running while pumping gas in order to avoid hard starts! I bought my purge valve from Amazon, it was easy to install, and an easy fix! It has outlasted the original one which started to cause problem at around 150 000 miles -- I don't exactly remember -- my van has more than 547 000 miles on it now, and I haven't had any hard start problems after filling up ever since!
@VasylGladun
2 жыл бұрын
I have 540K on my 2015 Transit, still original purge valve.
@armoricain
2 жыл бұрын
@@VasylGladun I am jealous! 😁
@sebastianromero4930
2 жыл бұрын
What’s the part number
Thanks for the info im going to change this someone told me it was the fuel pump but seeing how this fix so many people cars im going to try this first
@VasylGladun
2 жыл бұрын
Good luck. I hope it'll work for you.
Great video , thank you
@VasylGladun
3 жыл бұрын
Glad you enjoyed it
Just subscribed your going to save me lots of money not going to the dealership (2016 Ford Focus 1.0)
@VasylGladun
2 жыл бұрын
Thank you and you are welcome.
I just had this fixed on my 2015 focus however I was sent a letter from ford and they did the work and covered all costs . Look to see if you have a recall on your vehicle prior to fixing yourself !
@VasylGladun
2 жыл бұрын
Very good point. I did check, at that time Ford Focus 2016 didn't have recall for this issue.
@BLAV0
Жыл бұрын
how do i check ?
Thank you good video
@VasylGladun
2 жыл бұрын
Thank you for the comment
Mine just started doing that, check engine light on and I believe the code for it came up too, I did some digging and the code points to that as suspect. I’ll try that, unplug battery to reset everything snd see if it comes back on
@VasylGladun
Жыл бұрын
Good luck.
Omg I have a 2016 fiesta & it does this every single time.
Thank you, just changed my wife sister purge valve. It was very easy that her bf could’ve handled it himself 😂😂.
@VasylGladun
Жыл бұрын
Congratulations.
There's a recall on this and I took my 2012 focus in to get it fixed at the dealer. They said bc the fuel tank hadn't deformed yet that they there was nothing to fix. So they charged me a fee to inspect and fixed absolutely nothing. I argued and argued that the fuel tank is a result of the problem, not the problem and just bc it hadn't messed up yet, it is already showing all the symptoms of the recall. The rough idle, the rough start and/ or dying after refueling. They didn't fix anything.
That part is garbage. I just installed my second one yesterday at 137,000 miles (first one around 70,000 miles) on my 2012 Ford Focus Titanium 2.0L!! From my research, the one I installed today seems to be the third update (newest) version, part #BV6Z-9D289-R. And yes, both times I used genuine Ford parts from a dealership. Ten minutes to install, but still a PITA to have to deal with the hard starts before the part arrives and hoping the gas tanks does not deform (part of the recall stemming from this issue). Thanks for the vid.
@VasylGladun
2 жыл бұрын
137K for Ford Focus, not bad.
@manunava1776
2 жыл бұрын
@@VasylGladun Indeed! From the very first oil change, I have only used full syn oil, changed out at 5000 mile intervals sometimes at 6000. I took off the valve cover earlier this week to seal up a pesky oil leak with a new gasket set & a few dabs of rtv. I could not believe how clean it was with no visible signs of sludge build-up or any of the golden/yellow varnish build-up typically seen in a lot of higher mileage cars.
hi friend I would like to ask you for advice I have a Ford c max 1.8 petrol 2003 duratec engine the defect I feel and when I fill up the tank hangs the petrol nozzle keeps detaching and then if I accelerate the car seems empty as if there was a cap to the muffler or a lack of air or petrol this ford c max has the Cannister filter Activated carbon could this be the problem? thanks for your help
Great video but you should know that there is a recall for this issue. But doing it yourself will probably save you some time. Great video
@VasylGladun
2 жыл бұрын
Maybe it is now, but at the time I did repair this Ford Focus didn't have recall for this issue, I checked.
@TheMunich74
2 жыл бұрын
@@VasylGladun Thank you for this video , this would be the next step to do to avoid being talked into a diagnostic check $165 when the recall is stating FULL TANK DEFORMATION and TRANSMISSION CLUTCH SHUDDER.
@mre8ballgaming842
Жыл бұрын
As far as ik the only recall on my 2016 Ford focus is the fuel tank swelling
@jmaya7722
Жыл бұрын
Only recall for 2017 ford fusion se 1.5 L , is a steering wheel bolt replacement. Yet I'm having the same issues . Ford needs to recognize this is an issue in majority of Fords models.
It's a recall people. Look up ford focus recalls and it's the latest one. Posted in 2019? And it's mandatory for Ford to replace.
@VasylGladun
Жыл бұрын
About time. At the time I made this video this year and model didn't have this recall.
My 2015 just started doing that. engine light came on. runs fine but get gas wants to stall.
@VasylGladun
2 жыл бұрын
Looks like you have the same problem
@therealistjustin9015
2 жыл бұрын
Did u ever figure it out? It says i have a MAF issue. How’d you fix it?
What may the issue be if the car suddenly won't start at all after changing the purge valve?
@VasylGladun
2 жыл бұрын
Retrace your steps, check if all of the connectors are fully plugged in. Also you might check pins inside plugs if any of them are bent
Did that engine Light Came Up because Of that problem if so did it go away ? If not what kind Of Problem that was in you're car If you ever Got to Find Out?
@VasylGladun
9 ай бұрын
As you can see on this video, I did not use code reader so in this case it was a guessing game. When you fix the problem you have two options. First one to clear the code with the code reader, the second one is wait, because PCM doesn't reset itself automatically right after repair it takes a little time, some people say after 25 to 50 starts of the vehicle. In my case, check engine light went away after a couple weeks.
I have this problem....curious if this is why my car also tries to shut off while driving....when I'm not pressing the gas the rpms drop too low and it shuts off
@VasylGladun
Жыл бұрын
What kind of vehicle do you have?
@mre8ballgaming842
Жыл бұрын
@@VasylGladun 2016 Ford focus se
@gingerbecerraazua
Жыл бұрын
@@mre8ballgaming842 what did you do to fix it? Is it still shutting off when you drive?
@mre8ballgaming842
Жыл бұрын
@@gingerbecerraazua I changed out the evaporator purge valve and problem solved
Did your engine light came, an when you pump gas it stall
@VasylGladun
Жыл бұрын
Yes
I leave the car running when I refuel and avoid the restart problem
@VasylGladun
2 жыл бұрын
That's even cheaper solution. 👍
Check Ford recalls for 18S32....recall 18V73500
I have the same problem
@VasylGladun
Жыл бұрын
Before you do it yourself check with Ford, maybe it's a recall item and they can take care of it for you for free.
I'm having this problem with 2016 Fusion. Has same engine as Focus. Also, the gas inlet "farts"
@VasylGladun
Жыл бұрын
Before you do it yourself check with Ford, maybe it's a recall item and they can take care of it for you for free.
@tailgunner2
Жыл бұрын
@@VasylGladun I recently gotten a Ford recall notice, but it was for the front brake lines.
@tailgunner2
Жыл бұрын
@@VasylGladun I hit submit too soon. Thank you for the response.
@VasylGladun
Жыл бұрын
In that case good luck with the repair. It's not too difficult.
Does engine light go off
@VasylGladun
Жыл бұрын
I sold this car a year ago. I don't remember for sure, but I think it did go off after repair.
I have 2012 ford edge same porblem
@VasylGladun
2 жыл бұрын
Sadly many Ford models have this problem and only few covered by recall.
I have a 2016 ford fiesta and this happens every time!!
@VasylGladun
2 жыл бұрын
I sold this car few months ago so I can't tell you how long this repair will last, but it took care of this problem to the day I sold it at least. I would recommend before replying it yourself check if Ford doesn't have recall for this issue, because they do for some models with this problem.
What’s the part number?
@VasylGladun
2 жыл бұрын
I don't remember, but you don't really need it. Name of the part is "evaporator purge valve", you need to know make, model, year and engine size of your vehicle to get the correct one.
Does egine goes off after
@VasylGladun
Жыл бұрын
After what?
Current ford labor rate is $225 an hour.
@VasylGladun
Жыл бұрын
Not here in Indiana. Which state is this?
Why didn't ford just make the cannister itself replaceable??????
$25?? I had to pay $65 lol
@VasylGladun
2 жыл бұрын
Inflation...
Jus leave your car running while pumping gas. I been doing it for a year now.