Nice tip about the control valve! We don't do a lot of AC, but I'll be sure to keep this in mind!

@CoolAirVw

Жыл бұрын

No ac work in Canada? Why not?

Richard - outstanding video. Thanks again for your contributions here and at TDIClub. - scurvy

@CoolAirVw

6 жыл бұрын

Thanks.

I will feel guilty if I don't comment. Absolutely informative. With additional tip about condenser fan which I didn't noticed since 18 months of my service. Thank you sir

@CoolAirVw

4 жыл бұрын

Your welcome Thanks for watching.

Very well done and informative. Thank you

@CoolAirVw

3 жыл бұрын

thanks for watching.

great video!

I appreciate the video. I seen the high side pressure really high on a Miata before and the car was not cooling properly. After i washed out a lot of trash included dead bugs ect from the condenser the pressure dropped like a stone and the car cooled off. My TDI Jetta has always cooled properly unless the system was not getting power at the battery fuse panel until today . The car stopped cooling like it normally does. I keep a gauge in the duct just to be sure . After checking the pressure i assume the valve in the compressor is bad . I only seen this one other time . That time no pressure , this time its seems the compressor is doing just enough to cool a bit . Going to swap out the compressor with another one i have to see if this fixes the problem. . Thanks for the video

@CoolAirVw

6 ай бұрын

thanks for sharing your experience.

Great job 👍

@CoolAirVw

3 жыл бұрын

thanks for watching.

Whats a good source for these valves? I have noticed two different styles for these compressors.

its not just in AC that suck and blow works. but yes as a learning tool, it works really well!😁

@CoolAirVw

Жыл бұрын

memory technique.

Super vid! When you chiselled those two alternator bolts, where exactly did you strike? I'm curious, as you've clearly mastered this workflow :) I once changed out a compressor on a Mk4, but moved the front end out instead.

@CoolAirVw

4 жыл бұрын

drive it in. (in being the same direction the bolt would go if you tightened it.)

Good vídeo. Could you say me the part number of the oring seals for the ac compressor conectores for car ac circuit?

@CoolAirVw

2 жыл бұрын

dont have those sorry. they are pretty common sizes and I believe most local auto parts stores will have new o-rings. just take your old ones up and match them.

Excuse me sir where could I order this freeon control valve and gasket that you replaced?? I think i have this same exact problem my compressor seems to work just fine the clutch engages and everthing I replaced the fan, expansion valve and accumulator and still blows nothing but hot air...

@CoolAirVw

5 жыл бұрын

email me please. Find info on my website at www.kansascitytdi.com

Would my 1998 ALH beetle have that valve in my compressor cause I have a Freon leak at the seem where you replaced the Gaskets and I would love to save having to spend 300 to 400$ for new compressor. Then my other question is do you get that valve at a jobber? I have a company called Auto Camping up here in Ottawa Canada but I never asked if they have parts for compressors

@CoolAirVw

6 жыл бұрын

Most likely that is the same as your compressor unless your compressor was replaced with an aftermarket one. Take a look at yours and see if it says "sanden" on the green sticker partially viewable at 5:42. If so its probably the same.

@martinlavoie4002

6 жыл бұрын

CoolAirVw Rm thanks again I will check it out

I've seen alot of videos about a different control valve. Some of the compressors have it on the outside with a plug does this have the same thing or does it only have the one inside the compressor

@CoolAirVw

3 жыл бұрын

This is a mechanical valve inside the compressor. The other ones with electrical plug in (solenoid) come on clutchless compressors such as mk5 (2005.5 and up) jettas ect. We just put a RCV on a clutchless compressor on a Toyota Camry, and fixed the issue.

@WCxColosus

3 жыл бұрын

@@CoolAirVw ah ok i have a mkv so the compressor is similar to this one. Already ordered the part gonna work on it the Saturday hopefully everything turns out OK lol

@WCxColosus

3 жыл бұрын

@@CoolAirVw I changed the valve while I had it opened i noticed there was a good amount of rust. I put it back together and filled it but the clutch did not engage. I'm assuming the compressor is probably bad since it had rust inside?

@CoolAirVw

3 жыл бұрын

@@WCxColosus Rust inside is not a good sign.

Richard I follow yr instructions and me AC is blowing freezing cold but wen I rev the car I am hearing a rattling noise coming fr the compressor but it ok when it idles plz help me ifbu have any idea wat went wrong

@CoolAirVw

3 жыл бұрын

I cant know if you did something wrong or if there is a problem with your compressor or whether the noise is something else.

@rasheedmalcolm9611

3 жыл бұрын

@@CoolAirVw I think I realized wat went wrong I don't have compact tool and I think I bend the fan looking thing that the control valve go thru I had noticed that fan blade looking seal didn't cover one of the 4 holes at the time I wasn't certain if it shud be like that . I pulled up a old seased up compressor took out that part it's a little rusty tho I put it in some transmission oil soak gonna clean it up in the morning do u have any advise in that regard ? My AC freezing cold tho just the noise when I accelerate noise go away . Thanks for prompt reply

Where do you recommend I get a 2002 Volkswagen Jetta compressor rebuild kit ?

@CoolAirVw

Жыл бұрын

I don't "recommend" parts, nor do I "recommend" rebuilding them.

Popravio kompresor na Golf 3-ventil platio 25 eura-hvala!!!

@CoolAirVw

4 жыл бұрын

nema na čemu. Hvala što ste gledali moj KZread kanal.

How work control valve??

@CoolAirVw

Жыл бұрын

can't explain whole system here. I would mess up the explanation.