Replacing injectors & Glow Plugs Toyota Diesel. Toyota Prado. Fourby4diesel. Cleaning intake manifold. Intake manifold dirty from EGR EXHAUST GAS RECIRCULATION
Жүктеу.....
Пікірлер: 35
@Ramjet77774 жыл бұрын
Done mine I whiles ago. 2 of 4 where broken. One for a whiles and the other was broken on removal. Tried to get it out but it fell into cylinder. Wound engine over by hand and felt it jammed between cylinder and head. Pulled head off, the old broken tip had marked piston but seemed OK. Good thing I pulled head off anyway, pre com chambers were cracked but didn't damage head. Got head reconditioned with new pre com chambers, blocked egr and cleaned manifold. Replaced Injectors, fitted 3 inch turbo back exhaust, dp chip, wound boost up to 18psi with manual boost t and manual fuel cut defender to fool map sensor. Fitted egt sensor pre Turbo. Result = 30 - 40 % power and torque increase compared to even when it was new. Goes like a rocket.
@chrisanders49232 жыл бұрын
This video saved me, just did the plugs in my 95 hilux in the states and finding information has been tough and no shops have ever seen a 1kz. Used to run rough on the cold start and blow lots of smoke until it warmed up but it runs like new now. Thank you!
@lesleytisetso2515
Жыл бұрын
1.
@davecurry83004 жыл бұрын
Great video, thank you. Mine have been in for 16 years, 243,000 kms. I didn't realise how the tips would break off. I regularly service my vehicle, every 5,000 kms. Not blowing smoke, starts perfectly, happy with the engine overall, however, I better look into replacing them. Still running original water pump & a/c refrigerant, exhaust system, shocks. Car still tight. Auto oil & filter have been changed, no such thing as "sealed for life". Once again, thank you.
@SJ-po4hv3 жыл бұрын
Exact thing happened to my 1kz at 350k kms. No 4 glow plug tip gone resulting in cracked head. A few marks on piston top, but not too bad, bore thankfully ok. Advice from a mechanic mate of mine : “you should probably replace your glow plugs every 100 thou or so”. Oh well, you live and learn. Replaced head and all still going well at 430k. Will be replacing glow plugs in another 20 thou. Great vid, keep em coming.
@NovaSecurity1 Жыл бұрын
You guys are amazing. For some reason shops around here are afraid to touch the 1kz. Been learning from sparse information online. Just came across your videos and can not thank you enough.
@DeanMcGregor-eu4lt9 ай бұрын
I understand now. Change oil , clean fuel, air filter and rarely touch reg of engine
@sckennedy548 ай бұрын
thank you for the awesome video - very informative - subscribed
@anthonyyounghusband59174 жыл бұрын
Im totally enjoying your videos & im not a Toyota owner. "This is going to be a short video" LOL A BIG thumbs up from me,
@digitalbilly3 жыл бұрын
Great video!!!
@guntad12524 жыл бұрын
Good video. Thanks for the insight.
@joebaroudi22934 жыл бұрын
Thank you , informative indeed👍
@katouatebukinimata93214 жыл бұрын
Thanks for the video
@jonathanperry37924 жыл бұрын
1kz great vid.
@brothersole6360Ай бұрын
I like the video but I would like to know what could be the most culprit if my 1kzte diesel engine struggles to start over a night?
@sharazmohammed73693 жыл бұрын
Hi is it all brands of glow plus that the tips fall out or only the original?
@palace7614 Жыл бұрын
Good day can I have the number for 1kz te 120 prado injector.
@chriswright48513 жыл бұрын
What is the part number for the HKT glowplugs mate ? Unreal videos mate super informative ! Will be enquiring about a suspension kit very shortly !
@Fourby4Diesel
3 жыл бұрын
Cp22
@paganlife13732 жыл бұрын
Ever do continuity checks.?
@MADBONE04 жыл бұрын
Righto .. glow plugs for the 95 series 👍🏽
@cheeseburger3209 Жыл бұрын
What cleaner do you usually use on the manifolds?
@GomeSecks2 ай бұрын
What you prefere HKT or Denso?
@Ancillarbafana253 жыл бұрын
My 1kzte have black smoke no power hard to start we find water in de desiel
@wallyt37336 ай бұрын
I just recently bought a hilux and the engine has been shaking for the first 2 min on cold start is that a common thing on these engines or should i be worried
@jrgranados370420 күн бұрын
Hi i change the gluw plug and .do not work is some time else beford the glow plugs ?and can i have the link to bay new inyectors tkyou?
@GMans-World3 жыл бұрын
it doesn't make any noises when on idle
@Rasoglou9 ай бұрын
Can you tell me please where is the TPS ? Just cant find mine 1999 Toyota Hiace turbo diesel auto 3 lt import Auto 4WD
@Fourby4Diesel
9 ай бұрын
On the throttlebody
@MussaKZN4 жыл бұрын
6mm bolts !!
@harryharriott51923 жыл бұрын
I thought diesel don't use throttle bodies
@Beng177
2 жыл бұрын
they dont need them, it just helps the EGR work better with one iirc
@GMans-World3 жыл бұрын
I have this motor, it has a tappet/ticking noise, sounds like a single cylinder noise... would it be caused by a broken glow plug tip ??
@GMans-World
2 жыл бұрын
I guess no help or advise anyone ??? :) could it be shims or ???
Пікірлер: 35
Done mine I whiles ago. 2 of 4 where broken. One for a whiles and the other was broken on removal. Tried to get it out but it fell into cylinder. Wound engine over by hand and felt it jammed between cylinder and head. Pulled head off, the old broken tip had marked piston but seemed OK. Good thing I pulled head off anyway, pre com chambers were cracked but didn't damage head. Got head reconditioned with new pre com chambers, blocked egr and cleaned manifold. Replaced Injectors, fitted 3 inch turbo back exhaust, dp chip, wound boost up to 18psi with manual boost t and manual fuel cut defender to fool map sensor. Fitted egt sensor pre Turbo. Result = 30 - 40 % power and torque increase compared to even when it was new. Goes like a rocket.
This video saved me, just did the plugs in my 95 hilux in the states and finding information has been tough and no shops have ever seen a 1kz. Used to run rough on the cold start and blow lots of smoke until it warmed up but it runs like new now. Thank you!
@lesleytisetso2515
Жыл бұрын
1.
Great video, thank you. Mine have been in for 16 years, 243,000 kms. I didn't realise how the tips would break off. I regularly service my vehicle, every 5,000 kms. Not blowing smoke, starts perfectly, happy with the engine overall, however, I better look into replacing them. Still running original water pump & a/c refrigerant, exhaust system, shocks. Car still tight. Auto oil & filter have been changed, no such thing as "sealed for life". Once again, thank you.
Exact thing happened to my 1kz at 350k kms. No 4 glow plug tip gone resulting in cracked head. A few marks on piston top, but not too bad, bore thankfully ok. Advice from a mechanic mate of mine : “you should probably replace your glow plugs every 100 thou or so”. Oh well, you live and learn. Replaced head and all still going well at 430k. Will be replacing glow plugs in another 20 thou. Great vid, keep em coming.
You guys are amazing. For some reason shops around here are afraid to touch the 1kz. Been learning from sparse information online. Just came across your videos and can not thank you enough.
I understand now. Change oil , clean fuel, air filter and rarely touch reg of engine
thank you for the awesome video - very informative - subscribed
Im totally enjoying your videos & im not a Toyota owner. "This is going to be a short video" LOL A BIG thumbs up from me,
Great video!!!
Good video. Thanks for the insight.
Thank you , informative indeed👍
Thanks for the video
1kz great vid.
I like the video but I would like to know what could be the most culprit if my 1kzte diesel engine struggles to start over a night?
Hi is it all brands of glow plus that the tips fall out or only the original?
Good day can I have the number for 1kz te 120 prado injector.
What is the part number for the HKT glowplugs mate ? Unreal videos mate super informative ! Will be enquiring about a suspension kit very shortly !
@Fourby4Diesel
3 жыл бұрын
Cp22
Ever do continuity checks.?
Righto .. glow plugs for the 95 series 👍🏽
What cleaner do you usually use on the manifolds?
What you prefere HKT or Denso?
My 1kzte have black smoke no power hard to start we find water in de desiel
I just recently bought a hilux and the engine has been shaking for the first 2 min on cold start is that a common thing on these engines or should i be worried
Hi i change the gluw plug and .do not work is some time else beford the glow plugs ?and can i have the link to bay new inyectors tkyou?
it doesn't make any noises when on idle
Can you tell me please where is the TPS ? Just cant find mine 1999 Toyota Hiace turbo diesel auto 3 lt import Auto 4WD
@Fourby4Diesel
9 ай бұрын
On the throttlebody
6mm bolts !!
I thought diesel don't use throttle bodies
@Beng177
2 жыл бұрын
they dont need them, it just helps the EGR work better with one iirc
I have this motor, it has a tappet/ticking noise, sounds like a single cylinder noise... would it be caused by a broken glow plug tip ??
@GMans-World
2 жыл бұрын
I guess no help or advise anyone ??? :) could it be shims or ???
@cheeseburger3209
Жыл бұрын
Could be many things. Could be a belt noise.