You just saved my wife 1,000.00 dollars. Thanks

@stevewatr

5 жыл бұрын

You're welcome. Glad to hear it!

@glasser2819

4 жыл бұрын

beware... my dealer still insisted on saling me rack + pump job for a .50¢ seal

This worked perfectly for my '06 Pilot. Thanks for making it. Tip for anyone doing it- I purchased a new reservoir and drained it with a "quart fluid pump" so there was barely any oil left under the reservoir screen...seemed to make much less of a mess. Then, I put the new reservoir on and flushed it three times with steering fluid- you should have seen all the dirt coming out each time. Using the fluid pump made it a breeze to drain the reservoir. Whole job took less than an hour

Thanks this saved me money. Noise gone instantly in 08 Pilot with only the bottom ring replaced. Used a little 10mm wrench from a short Mastercraft set. With lots of finger work. Don't drop the bolt in the engine like I did. Stuff your rag way in there against the engine so u don't need a magnet stick to fish it out. Thanks again.

When you purge the air out you have to leave the reservoir cap off so that the foaming fluid can release the air. Usually it takes 10 turns to the right and 10 turns the left lock to lock. And yes new fluid does help.

@brandonhvacants2217

4 жыл бұрын

Thanks nicco

@solibay2006

4 жыл бұрын

does the engine have to be running to do this?

@JG-sq7it

4 жыл бұрын

@@solibay2006 Yes, the engine must be running. If the pump is not turning, no fluid is flowing.

You had me at the word cavitation. Thanks for your due diligence and helpful information. Fixed!

Great video one of the best I've found to explain the power steering orings

the key is to embrace holding the stubby 10mm wrench with left hand while the right hand merely holds, mind you awkwardly, the box wrench head on the bolt itself- with full contact.

MUCHAS GRACIAS ME AYUDO MUCHO EL VIDEO Y YA NO HAY RUIDO EN MI DIRECCIÓN ASISTIDA. SALUDOS DESDE MEXICALI BAJA CALIFORNIA MEXICO

My 04 Acura Mdx has same problem. So It is helping me. Thanks a lot.

Great video, quite details instructions. How did you flush-out the old power steering fluid Steve?

Good stuff. About to do this myself. Seem like if the fluid is low or leaking the o rings are more likely but if fluid ia dark it just needs a good flush first. Now you attached your coupling and hose at the return of the reservoir?

Great tutorial. Thanks for posting.

Thanks for the vid. I wanted to just clean out my reservoir too instead of paying 50 bucks for a new one at the dealership. Was it easy to clean out? Will just spraying brake cleaner in there melt the shit off the screen without melting the screen? You think I would need a air compressor too to blow it out?

Thanks I’m going to go check mine I got same problem in my 06 ridgeline with 190k miles.

Thanks a lot! Didn’t even have to touch the reservoir

Thank You for sharing this video!

Saw the same thing on our 2004 Accord. Same red O ring. 5 buck fix.

If you can't get that little nut on/off, removing the pump isn't too bad. Also check the pressure hose o-ring on top (has 2x 10mm hex bolts on top of pump). If > 200k miles, take a look at the rubber hose portions of the pressure line on top, as the rubber will get checked/cracked over time and will develop a leak. If you're replacing the pressure line, you'll only need a 10mm socket and a 14mm crows foot flare socket. The flare nut is a to get to, but it's not too bad. It's not difficult, but tedious. You can replace the pump, pressure hose and reservoir for $130 on Amazon. That reservoir has a filter integrated into the bottom of it.

@stevewatr

2 жыл бұрын

Lot's of great info. In my case the orings were all I needed at the time. We ended up trading this car in towards a new CRV after we found out the rear suspension mounts on the body had rotted off, and would have been a lot to repair.

@DJtheDad

2 жыл бұрын

@@stevewatr Our 2007 Pilot EX-L is still running strong at 230k except for this P/S line. I've only replaced the radiator and alternator previously. Otherwise it's been a great SUV. Hardly any rust on this thing either, and we're in NW Ohio with salty / brine-laden winters. Garage-kept. Rubber control arm and suspension bushings look like they've got another winter left but that's it.

The 94-03 accords had the same issue lol. The hoses are alike as well. I just clean out my resevoir if the screen isnt broken.

ATG said to beware dishonest dealers & shops will say Engine Valve Job or Power Steering Pump needed. Which is close in $1,000.00+ jobs. ATG suggests to buy Harbor Freight Tools and buy O-rings multi accessories (in plastic container). Then jack front wheels off the ground. Keyed on but no need to start the engine. Turn Steering Wheel left to right (end to end) and check for bubble. Make sure to check that Power Steering Fluid is not low. You may have to turn more than 51 times.

This was very helpful! Thanks!! :)

excellen! thanks for the video

I had this same issue I replaced the power steering pump Added new seals for high pressure line and the pump seal Drained everything out of power steering fluid Added new fluid and performed the cycles of Turning left to right 10 times No noise anymore

i bought a 2003 accord 3.0 v6 and it had the loud noise on the power steering. the reservoir bubbles up, leaking fluid on the bottom. checked for recalls and they replaced free the high-pressure steering hose and an ignition key component. after replacing the new high pressure hose it still has the same noise and bubble in the reservoir. i figure i need to replace the new red o-ring . so i bought it for $3, a new reservoir with the two hose that connects it. gave it to my mechanic friend and after that, no more noise and leaking.

Great video bro

I have had the same problem with my steering pump. The problem solved partially. Finally, I replaced the reservoir. The reservior contains micro pores and when it become dirty and contiminations deposite in it, it needs to be replaced by new one not cleaning and washing it.

Great video! Thanks for all the information. Looks like I have some work to do.

Was the steering wheel difficult prior to flushing out the system and installing a new gasket? My system is noisy but also hard to turn. Just trying to diagnose my issue. Thanks

@stevewatr

5 жыл бұрын

This is my wife's car. Neither of us noticed anything different about the feel of the steering before or after the repair. It was just an unusual noise.

@solibay2006

4 жыл бұрын

if your steering gets hard, i guess the pump is gone

@talmoskowitz5221

2 жыл бұрын

I can feel jitter in the wheel as I steer shortly after starting the vehicle. It then became smooth in less than 1/10 mile, but intermittently it took more strength to turn the wheel driving at 20 mph.

I have the dreaded Honda Ridgeline "buzz" with my power steering. I'm hoping its the O-rings, but I don't see bubbles in the PS reservoir, did you have bubbles in yours?

@stevewatr

7 ай бұрын

I can't remember. But the orings are so cheap and easy to change, I'd say try it.

Its #1 reminder gotta go to the scrapYard, wiwax! Transmission gonna be next xD

Thank you

I've been reading that how this is the fix, just trying to figure out HOW an oring can cause a noise? Is there air entering causing this?

@stevewatr

5 жыл бұрын

Yes, the noise is cavitation caused by air entering the system on the suction side of the pump.

Hi did you have to remove the power steering fluid from the system?

@ricebike

4 жыл бұрын

did you see how black the fluid is? it's recommended to change out the fluid from time to time & he's mentioning what's common in these hondas/acuras power system problems. just make sure you get fluid that's for HONDA / ACURA

I think this is my problem with my Odyssey. I'm going to tackle the project this weekend.

@deasttn

5 жыл бұрын

Well, I changed the I rings and it appears that someone beat me to it (I bought the van, used). I'm hoping there's not a bigger problem somewhere

I got the same problem. I’ll try what you did.

What is the part number for the o ring, I have 2006 honda pilot?

@ricebike

4 жыл бұрын

get a set for both the pressure and suction sides. pressure is black, suction is red as shown on this video. i scored a set for a mere $2.02 on eBay. it's all the same sizes for hondas/acuras it seems when i was researching this infamous problem

A guy replaced the top O-Ring and that stopped the noise and the froth in his power steering. He didn't wvwn replace the bottom O-Ring

Mine makes a groaning whirring noise. It also gets louder when turning the wheel. Same problem/solution? Thanks.

@stevewatr

4 жыл бұрын

Could be. If the fluid level is okay, try the springs, they're a cheap enough part.

@jburgess9578

4 жыл бұрын

@@stevewatr Thank you for replying. I'll look into it.

I have the same Pilot. Mine only does this noise when I start up the Pilot in the morning. The noise fades away completely once the car is completely warm. Is this the same fix for it? I've checked the fluid levels they're fine.

@stevewatr

5 жыл бұрын

It might be. My understanding is the bad o-rings allow air to be sucked into the system. This causes cavitation in the pump. When it's cold, the orings may be leaking more air, then as they warm up, they expand and seal better. Just a theory.

@samuelgalvez8575

5 жыл бұрын

@@stevewatr thanks for the prompt response. Great tutorial video btw. I am ordering the rings and giving it a shot.

@MrKim-hh9fb

5 жыл бұрын

So did replacing both o rings fix the issue?

@stevewatr

5 жыл бұрын

@@MrKim-hh9fb in my case it did.

@normdeplume4082

5 жыл бұрын

@@stevewatr or was it the flush?

Awesome! 2 hours of overtime and I am still first! Booyahhh! Where you at, JS?

@stevewatr

6 жыл бұрын

Lol, Maybe John is getting tired of Honda Pilot repair videos.......I know I'm getting tired of working on it! This should be the last Honda Pilot repair for a while......hopefully.

I replaced both o-rings and i still have noises and bubbles in tank

Turn your wheel lock to lock a couple times to bleed the system.

I recently got my timing belt, water pump etc replaced. Yesterday morning the power-steering reservoir was over leaking. I have the noise when during start up and turning the wheel at park. I hope this is a simple fix like this .. I have a 2007 Honda Pilot @ 205k miles. Thanks for making this video

@stevewatr

5 жыл бұрын

Keep in mind a low fluid level can also cause this noise. Figured I'd mention it since you mentioned a leak.

@saulluna98

5 жыл бұрын

How much was it to get water pump and timing belt replaced I have a 06 honda pilot and ive been told i might need to get that replaced i wanna see what to look forward 4th o

@RobbiePfunder

5 жыл бұрын

Saul Luna hows it running at 205k? Have you replaced the timing belt and pump at all yet?! I have a 2005 w 162k and do a lot of towing.

Please help I'm so scared it my rack, I'm praying it's just this

@stevewatr

Жыл бұрын

Unless you have very high mileage, it probably is not the rack. Unless the rack is leaking fluid, then I would just try the orings. they are so cheap, and this was a guess I made that worked out for me.

You should have replaced BOTH of the O-Rings.. There was NO Difference in the Noise, after you changed just the 1 O-ring.. Do both O-RINGS And bleed your power steering fluid.. Hopefully this info helps.. I don't think you know/Knew Exactly what to do and how to look for it and do.. . 🤞🔧🔧🔨😄💪🤟👌

@stevewatr

2 жыл бұрын

I mention that both orings should be replaced. If you watch the last part I show how to clean the screen in the reservoir. After that I flushed the bad fluid out and the noise went away.

@Afghan-Pride-Till-I-Die

2 жыл бұрын

@@stevewatr Buddy the pump was still not working correctly.. There was still noise coming from the pump.. I'm really sure you need a new pump... All the work you did should have made no noise AT ALL.. Good luck bro! 👍🤔🤞🔨🔧🎯

@TomTomTom87

7 ай бұрын

Replacing the O-rings and/or reservoir doesn't make the noise instantly go away. As others in the comments have said, you need to turn the wheel multiple times and drive the vehicle to expel the air bubbles still in there from the prior PS fluid, once that is achieved the sound (usually) goes away.@@Afghan-Pride-Till-I-Die

Honda PS pump $452.

@stevewatr

5 жыл бұрын

Ouch! Glad in my case the oring solved it.

@AlexFlockhart

3 жыл бұрын

Yikes. That's a quarter of what I paid for the car