Family Morris Minor 1000 hasn't driven in 30 years. Sequel to "Will it Start?" • 1967 Morris Minor (Wil...
Жүктеу.....
Пікірлер: 168
@saintjohnno9 ай бұрын
Reminds me of when l was a teen tackling these old type motors... We had no training just a little bit of nouse and learn as you go.. Those engines were so simple compared to the modern day engines .. Today ' you lift the bonnet take one look then shut it up again... l once pulled a motor out of a Holden Gemini ' reconditioned it and put it back in again , thats how user friendly they were back then.. im now 78 years old..
@jamesgibson5606 Жыл бұрын
They were a classic of their time, a very unique sound from that 1 litre engine. Great video.
@davebdave1
Жыл бұрын
Thanks, I love the engine note combined with that first gear whine
@jeremiahchamberlin4499 Жыл бұрын
My first car was a 1959 Morris Minor. At age 16 I learned a lot about cars with that model. Required vegetable-based brake fluid, proper installation of front wheel bearings, desirability of synchromesh in 1st gear, necessity of damping oil in SU carbs, proper centering of jets in SU carbs, desirability of decent oil cooler in California and/or cross-country trips, ineffectiveness of low-compression pistons, downside of shaving the flywheel (ring gear eats a hole in the oil pump), non-necessity of turn signals as standard equipment . . . I could go on, but I think I’ll stop here, I think you get the picture.
@RaulRamaMurthiSUBRAMANIAM10 ай бұрын
Thanks to you guys for givin her a second chance.. ❤❤❤
@cyclist3969 Жыл бұрын
Those engines, not actually Morris, but Austin, 3-bearing crankshaft, pushrod valve operation were still in production until the year 2000, although unrefined, "tappity" they had a hard to beat combination of drivability in a wide torque curve and low fuel-consumption, Harry Weslake was the engineer behind the cylinder head which gave these engines those characteristics. Another aspect, even after high mileage, they were good first time starters in all weathers, deep winter or high summer, something which the equivalent engine from Ford could not match
@laing685
Жыл бұрын
thanks for showing it was a bit like back to the future lol i enjoyed it
@harrymorton127411 ай бұрын
Did everything in a Morris minor .would pull the car over onto a square bale and change the clutch. I think I did it all with a 1/2 inch And 9/16 spanner. Owned 5 in the day still wish I had the traveller. Brakes were terrible the shaft would seize under the floor Matt and the cylinders would seize. But the engine would always start with the starting handle. Simple car. No fancy electronics. Loved them.
@Falconurbex Жыл бұрын
Love old cars like this with the old style engines and S.U Carbs they are such a pleasure to work on just like the vw bug so easy to pop the engines out ,thanks for the upload it was a pleasure to watch.
@redmann31567 Жыл бұрын
OH WOW!!!! I am so happy to see this kind of video!!!! This reminds me of when I first got my 1960 Morris Mini!!! I had so much fun getting that tiny car Road worthy again!!! My neighbors even asked if they could ride along on test drives!!! ❤😊😁
@davebdave1
Жыл бұрын
Thanks I’m not sure when the Morris will be roadworthy again but I’m already planning the launch party.
@redmann31567
Жыл бұрын
I will definitely watch your videos, notifications on sir!!!!
@douglasmesina6922 Жыл бұрын
Lol, I didn't read the description and thought it was a Beetle. Trying to figure out who put a vertical 4cyl in It. Too funny
@jeffreyguilbert808 Жыл бұрын
I love the Morris minor
@felixmadison5736 Жыл бұрын
Damn! I'm 74 years-old and I haven't seen a Morris Minor in years! In fact, I had forgotten all about them.
@TheGreatest1974
5 ай бұрын
Apparently there are still 30,000 of them on British roads?! Yes- amazing eh? There’s a few places in England that all they do is Morris minor parts & repairs. Any part you want you can get. Other places concentrate on restoring them to pristine condition. Great eh? I’m 53 and I would LOVE one but I can’t afford one, although you can get one running well needing a little weld here and there for £2,000. But restored to better than new with a Morris 1275cc engine in it is up to £30,000!
@PeterClement-mm6qk9 ай бұрын
I'm in New Zealand. Morris Minor is a Classic icon. In the '60s there were thousands on the road in NZ. Japan copied this reliable OHV motor for the first Datsuns produced post WW2. Early series were side valve, then moved to OHV (1954??) Humourous watching US car shows repairing old pommy cars. 😂 Great watch. Cheers
@jebsails2837 Жыл бұрын
My high school English teacher had a slightly older convertible (drophead?). I watched him enter the building soaking wet as the top leaked if a passerby spit on the sidewalk. The final straw came while he was proceeding up a small local hill and being passed by a vespa (not the prayer). Narragansett Bay
@davebdave1
Жыл бұрын
LOL, as Dan said they are great on Florida flatland, I’m not sure how it would do on a hill as I’ve never driven it up one. This does have the bigger 1098cc engine.
@PeterShaw-lb9lt
Жыл бұрын
Are you guys getting desperate working on English cars I worked on to many here in Australia they were very common and a pain to do anything too
@ganpatraogole789611 ай бұрын
I have a 1952 Morris minor 4 door side valve Engine with Dashpot front suspension system , leaf spring rear suspension. Not in working condition for over 15 years it gave me excellent service . Now parts availability is problem
@robleary335311 ай бұрын
Love seeing old bits of kit being bought back to life!. 🤣 Nice one!. Nuff said!. 🙂
@MiniorMinority3 ай бұрын
Lovely to see it running, and great memories. I fear that with so much rust it might be the last time 😢
@davebdave1
3 ай бұрын
Thanks, It won’t be anytime soon but I’m confident we’ll get it on the road again. I do think I need to hurry up and buy the replacement metal while it is still available.
@pedrokd5439
2 ай бұрын
Morris minor spares in the UK have every part for rebuilding an MM.
@lanfrancosenno7536 Жыл бұрын
Complimenti..buona per la vostra passione..bel modello di auto...operazione di recupero all'altezza delle aspettative. 😊
@billmorrison4746 Жыл бұрын
An unmistakable sound from the old peashooter exhaust ❤
@519766143911 ай бұрын
Lucky the thermostat housing wasn't corroded to the block and the studs ! If I remember correctly, when you get to the master cylinders under the floor you'll find some of the nuts/bolts are 1/4 Whitworth..... does get more old school than that !
@RaggyAl197111 ай бұрын
Had a 1966 saloon,sold it to a guy who said he was going to finish the restoration off,he didn't.Instead he scrapped it!!!
@davebdave1
11 ай бұрын
That’s a bummer. They are fairly rare here in the U.S.
@spmqqse5621 Жыл бұрын
i had a 1952 flthead lhd ....i miss it... the back seat was well used during thye hippy '60's...[nudge/nudge]
@loki7441 Жыл бұрын
You can get nearly every part you need still for the "Moggy" in the UK. And reasonably priced as theres a huge following for them still. As a rare care in the States it would be well worth restoring. They are actually quite a smooth car on the road, fast they isn't by todays standards but a simple piece of car to keep in the road.
@davebdave1
Жыл бұрын
I’ll see a Morris at the larger car shows but I haven’t seen one out on the road in years. There are a few parts suppliers here in the States so I’m confident we can save it.
@grahamepigney8565 Жыл бұрын
My father had a Seriies V Traveller in which we had a memorable holiday around 1970 camping in France, Switzerland and Italy. Rather later in the '70s we had a 2-door Series III as the family car. Dad bought it for Mum to drive and my brother and I to learn on. The deal was that Dad put up the purchase price and that was it, we had to service and repair it ourselves with Dad's tutelage if required. They had weak 1st/reverse gears and we had to change 2 or 3 gearboxes sourced from the scrap yard. We eventually came across a unused Gold Seal (BMC refurbished) gearbox and that was the last one we fitted. We were pretty adept at whipping out the front seats, taking up the part of the floor covering the gearbox/clutch and swapping the gearbox, a Sunday morning job. The brakes were a pain as the wheel cylinders seemed to seize on a whim and always needed changing for the MOT. Dad's insistence on us maintaining repairing it is principally what has enabled me to maintain my own cars over the years up to and including our current BMW E39s. As teenagers we had ideas about dropping Midget brakes and engine into it but this remained a pipe dream. My first car was Series V Moggie 1000, given to me by my grand-father when he gave up driving. It didn't last long. In common with most BMCs at the time the tin-worm was quietly chewing away at the floor and sills. It was his 2nd Moggie. He had a Series III that he had traded in for an 1100. The 1100 never did find favour with him and with some expensive rust repairs required on what was a nearly new car he got shot of it and bought the Series V. His brother's one and only car was a Series II convertible, it would be worth a bob or two these days.
@davebdave1
Жыл бұрын
I had forgotten but we did replace the gearbox at some point. I don’t know where my Dad found it.
@chrisquinlan3012 Жыл бұрын
My first car was a 56 Tourer top,driving around I started to morries stopped on the side of road with front wheel at 90 degrees to normal.Jacked mine up to have check.....rusted out frames seemed to a common thing !!!
@ixavore7067 Жыл бұрын
Beautiful colour
@davebdave1
Жыл бұрын
Thanks, my grandfather painted it for me in 1986.
@nygelmiller5293
Жыл бұрын
@@davebdave1 now you just need to emphasize the w h e e l s and grille bars, by painting them the whitest of white. (I think they ARE white, but getting a bit yellow, like an old tennis shoe! The factory colour is sort of cream, and hideously old fashioned!
@nygelmiller5293
Жыл бұрын
I didn't own one of these myself, but, like everyone else in the U.K., I have been IN these cars . After all, they were the first million selling car in the U.K.!
@RODALCO200711 ай бұрын
Brilliant video.
@davebdave1
11 ай бұрын
Thanks
@harshabiliangady3211 Жыл бұрын
Seen many of these Morris Minors in India and WOW they were terrific. But yes this is a first, a single door and a Left Hand Drive.
@hannetjiescheepers9819
Жыл бұрын
How must it Run You Doos It has no feet (POES KOP)
@eddiemillichip Жыл бұрын
well done getting that old thing going, and doubly well done for getting anywhere without a clutch! greetings from a fellow moggie owner in england, best of luck getting that motor sorted 👍
@davebdave1
Жыл бұрын
Thanks, just the beginning of a long journey to get it back on the road. They really are fun cars
@SunofYork
Жыл бұрын
I had two of these in the early seventies. The suspension collapsed on reverse in the police station parking lot ! It is a 'torsion bar' suspension and it whipped the bottle jack up past my ear ...almost killed me.... I had a long history with A type engines...(A35 Van , minis, Farina A40) then B type in a Marina rot box... I LOVE Toyotas nowadays. I have zero nostalgia for those days... British cars and bikes were crap compared today's Jap cars.. ...eg Kawasaki 1000Sx bikes ... I only spent 59 years in England then left
@utcherry Жыл бұрын
Love it! The little engine that could 😊
@jeffreywhitmoyer860 Жыл бұрын
Grew up with a Morris Minor. We stuffed 11 people into it when visiting relatives, just a bit cramped. My first car was a Morris Oxford. At the time, I didn't appreciate either one of them. Went on to an assortment of British sports cars, including hill climbing a Spitfire. Miss all those relatively crude cars.
@davebdave1
Жыл бұрын
LOL, It was common for me to have 6 or 7 in the Morris driving friends home after school, but never 11.
@anthonyroger5533 Жыл бұрын
Love ❤ this little 2door car!!
@KiwiCatherineJemma Жыл бұрын
CLUTCH SEIZED INFO... Previously the following has worked for me...warm up the engine in neutral. Then switch off. Then select first gear, (or reverse), and start the engine. The car will lurch and start driving forward (or backward). Remember this is decades before those silly new safety laws about "foot on the clutch to activate starter", (none of my cars have EVER had that). Now as you drive the car around the yard in first/reverse accelerate and deccelerate in a jerky fashion. This will often enable a stuck clutch to become free. Job Done !
@jerryreed1044 Жыл бұрын
We owned four of these moris minors at one time they were all great looking cars, ran and drove like champs. Loved them we were told that only 75 of them made it to the USA!! I know where 2 are here one convertible and one is a woodies wagon garage kept and never sold!!
@charleymendesdesousa567 Жыл бұрын
my Brazilian Air force mechanic father,had a Morris 😁
@grahamepigney8565 Жыл бұрын
Oil in the dash pot will improve the operation of the SU carburettor. Not sure that red engine is a factory rebuild. Here in the UK at least, factory rebuilds were "Gold Seal" and painted accordingly. From memory, and it is about 50 years ago now, rebuilt units didn't come with ancillaries (manifolds etc) so wouldn't have been painted in the same colour as the block/head.
@davebdave1
Жыл бұрын
I don’t remember where my dad found the engine but my memory tells me it might have been silver. I think I painted it red with leftover pint used for a Chevrolet engine. Next time we work on it I’ll scrape off some red and see what’s underneath.
@grahamepigney8565
Жыл бұрын
@@davebdave1 if I recall correctly you can tell the origins of the engine (capacity, type of vehicle...) from the prefix of the serial number on the block and a factory remanufactured engine will have its own prefix. I think I've got some documentation around here somewhere. If you let me know what the first 4 characters of the serial number are I can probably check them.
@user-so6oi2iw2y9 ай бұрын
Nothing could be worse than the fear that one had given up too soon, and left one unexpended effort that might have saved the world.
@stephenvictorbailey4055 Жыл бұрын
Ive owned 2 of em...that engine is basically an upgraded mini engine
@ukuleletyke
9 ай бұрын
The Minor came first, and before that, it was, I think, the old Austin A30 engine. So the Mini got an upgraded A30 engine, with a gearbox in the sump.
@enriquelopez9124 Жыл бұрын
Nice t9 see that you got the Morris Minor Is moving even with some help, nice to see that the Morris still has the manual start up method in the front like most cars had way back in the day.
@davebdave1
Жыл бұрын
Thanks, I used to crank start it just for fun. People would see me start it and tell me about their early cars.
@jmaxx88shsu Жыл бұрын
I have my grandpas Morris Minor. Its in way worse shape but I got it to run after 45 years of sitting.
@davidwhitman9609
Жыл бұрын
That’s excellent! They are amazing cars.
@simplyclosetonature240311 ай бұрын
Excellent job done. My escot tractor is not is use for 10 yrs will it work now, if ys what important to check.
@duncandemontfort51569 ай бұрын
Amazing 😂 you guys are hilarious Great piece Was my first car too 😅
@davebdave1
9 ай бұрын
Thanks! It’s an excellent first car!
@marciasantos4180 Жыл бұрын
em sao paulo anos 60 ate inicio dos anos 70 so tinha este modelo de veiculo nao encontrava outro
@user-oh2xs5lt7c9 ай бұрын
Summer of Love reg. That back seat was busy ha
@46spanner Жыл бұрын
The clutch pedal, and the brake pedal, pivot on a shaft at about floor level, it’s quite possibly that it has seized on that shaft
@rajeshparmar8882 Жыл бұрын
My feverit car
@nygelmiller5293 Жыл бұрын
This car smartened could be a nice looking car. I once saw the rival to this car, the Austin A30/A35, in exactly the same shade of metallic blue.( silvery metallic blue). A non- factory finish. It occurred to me that METALLIC finishes particularly suit such curvy cars. In the metallic colours, you see a light and shade effect on the curves! Also, the smaller lights under the headlights look particularly nice, because they MATCH the headlights. Unlike in the U.K., where the small lights are ORANGE/WHITE FOR THE TURN signals/ running lights.
@davebdave1
Жыл бұрын
Thanks, My grandfather convinced me that it would be the best color for the car. He also painted it for me in 1986
@markmartin524811 ай бұрын
That was great fellas.
@davebdave1
11 ай бұрын
Thanks!
@mick0846 Жыл бұрын
Lovely little cars
@zunifaramri8028 Жыл бұрын
Di takengon aceh tengah di masa aku kecil di tahun 1970 banyak mobil sedan morrys ,chevrolet ,willys ,jeep ,impala, toyoved, jeep, jazz mobil rusia,gmc ,dodge, layland,nissan patrol,disini angkut penumpang dari kampung kedaerah kota lain ,
@finncarlbomholtsrensen1188 Жыл бұрын
My long time late Grandfather had two of these, the last from 1959 (The former needed new tires, and he came home with a new car, a new model 1000, a little scared for my Grandmothers reaction!). I think he had to lock it from the passenger side (Denmark)? In its heated store room it had blankets for protection on top, and if rain, my Grandmother had to use a bicycle! My Grandfather himself could laugh from this, but it wasn't used during rain, unless unlucky to happen while driving!!!
@davebdave1
Жыл бұрын
I love this story, I would like to have met your Grandfather. This Morris had a different life. It sat outside in Hurricanes and was driven in rain so heavy the windshield wipers couldn’t keep up.
@alanb5370 Жыл бұрын
It looks like the colour was originally smoke grey, which eas in reality, a light blue. I have a 1966 4 door in store here in the UK, which comes out in the summer.
@davebdave1
Жыл бұрын
Thanks, I didn’t know the name for the original color.
@geofflewis8599 Жыл бұрын
..and the thing about Morries, is they only need one tool, genius British design..12lb Hammer..
@nikjames2965 Жыл бұрын
Your Minor has the ribbed case gearbox, which is far better than earlier smooth case... It should also have the 1098cc engine - a mighty 48 Bhp
@juliocesarcosta3251 Жыл бұрын
Very good , fantastic ,,,,
@davebdave1
Жыл бұрын
Thanks!
@shahzadbacha517611 ай бұрын
نہایت ہی خوب Very lovely car, these cars was used in Pakistan as a taxi
@pedrokd54392 ай бұрын
Good job
@zunifaramri8028 Жыл бұрын
Selain morrys ,di masa tahun 1970,ada juga kulihat di takengon mobil land loverd ,vw volg wagen,fiat sedan renauld ,mazda .
@thomasmatthews47668 ай бұрын
Save the old girl....Every part available ...lovely old cars...i have one here in uk...👍👍👍
@MegaRetr6 ай бұрын
Incredible video😊
@davebdave1
6 ай бұрын
Thank you!
@stephenlutchman2101 Жыл бұрын
I had one in Trinidad
@robertswanson5269 Жыл бұрын
Dave, glad to see you’re still wrenching on stuff pretty cool stuff here
@davidwhitman9609
Жыл бұрын
Thanks Rob! I’ve got project cars spread all over, just not enough spare time to finish them. It’s fun working with my nephew Dan although he’s got even less free time to work on his stuff, LOL.
@robertswanson5269
Жыл бұрын
@@davidwhitman9609 that’s what it’s all about!
@Synthematix9 ай бұрын
Lucas makes excellent points, shame the same cant be said for his last film
@davebdave1
9 ай бұрын
Lol
@stevethegreasemonkey7 ай бұрын
That A series engine was just about bullet proof
@davidgreenwood5241 Жыл бұрын
Radio looks pretty good
@davebdave1
Жыл бұрын
LOL, I mounted it to a wood panel to isolate from the Chasis which is Positive ground. I spent some time making sure everything was isolated from the car’s metal but that was before the internet. I now know that I could have just switched the battery to negative ground and re-polarized the generator in a matter of minutes.
@davidgreenwood5241
Жыл бұрын
@@davebdave1 ye even before cd that one
@hlaokaboutfightiganimalstun11 ай бұрын
Very good Morris miner .❤❤❤❤❤❤❤.။။
@blewanthanaveris6901 Жыл бұрын
Criminal! Not cricket! Left hand drive. Oh the pain, the pain.
@nygelmiller5293
Жыл бұрын
Left hand drive? On the other hand, a good selling EXPORT car!
@davidallen4712 Жыл бұрын
I thought any Moggies in the states wouldn't rot like they do here
@DMiddleton-bj5wcАй бұрын
Made by the British Motor Corporation ( which included Austin, Morris & MG) in the year before they merged with Leyland ( which included Rover, Triumph & Jaguar) to become British Leyland. One of the major problems was that the marques continued to see each other as rivals every time there was a merger - even though they were part of the same company. This could lead to bad decisions being made eg the Triumph Stag engine could have had a much better Rover engine, but Triumph went for a poorer modification of one of their engines. Sad, because some of the products such as the Morris Minor were fantastic!
@jamesd6449 Жыл бұрын
More morris content plz! If u can fix the rusty framing that would be good 😂
@davebdave1
Жыл бұрын
Thanks, The Frame is our next priority
@hutchcraftcp Жыл бұрын
That block needs a CLR treatment 😮
@davebdave1
Жыл бұрын
Yes, the cooling passages are bad. We are going to do some more cleaning as I’m worried about hot spots around the cylinders. Might try CLR
@herbertvanrensburg641111 ай бұрын
Great little cars, have you managed to repair the clutch yet?
@davebdave1
11 ай бұрын
Haven’t had a chance to work on it. We’ll post a video when we do, hopefully soon.
@richardbourassa111311 ай бұрын
Why do you use your wrench’s backwards?
@roberthorseman7432 Жыл бұрын
Bit strange seeing one of these with left hand drive.
@richarddavis3007 Жыл бұрын
Take a scaper push it in between the clutch and flywheel
@virgvision Жыл бұрын
14:03 😂
@benhur_93773 ай бұрын
❤
@LawnMowersThingsThatMakeNoise11 ай бұрын
it should be a 1098CC engine lol not that 98cc makes much difference but i have owned one myself and they are a hoot to drive 🙂
@enriquelopez9124 Жыл бұрын
Those old British classics have engines that can go on an on not like the newer cars where even the simplest thing can ruin a car.
@davebdave1
Жыл бұрын
If it weren’t for the rust it would already be back in service. The remaining mechanical problems are minor
@frederickherring228411 ай бұрын
My first Car, Paid $70.00 for it. Drove it aroun,d, illegally of course cos I didn't have a license, The I got my call up and it sat outside my mum's house for about eleven months while i was away. Came home on leave, got my license, then traded it for a red Escort, got $200.00 . good car , windows taped up cos the winders didn't work. Rust holes in the floor, but you couldn,t stop it.
@marvinkumarparboteeah782213 күн бұрын
"what is wrong ...with this car...? thanks , i enjoyed your video
@sgt.pembry9688 Жыл бұрын
Lucas electrical system = Prince of Darkness
@davebdave1
Жыл бұрын
LOL, I’ve heard that but I never had any electric issues in the Morris except for the SU fuel pump randomly quitting until I rapped on it with a screwdriver.
@narrowbeamdaydream
11 ай бұрын
@@davebdave1 The SU fuel pump was not made by Lucas
@charlesyoungblood1402 Жыл бұрын
Sweeeeet !
@anthonyroger5533 Жыл бұрын
Once it's fixed is it better than the classic VW Beetle?
@davebdave1
11 ай бұрын
I think it is but Bugs are cool too.
@molemarden5188 Жыл бұрын
You know when the postman was about in minor by the sound
@keithwalker689212 сағат бұрын
Can I get one in Ontario canada
@rajeshparmar8882 Жыл бұрын
I like it morees
@constructdestruct360 Жыл бұрын
33k views in 6 days.!?
@kevdavis320711 ай бұрын
Will it run and drive???? Of course it will. cars were built properly in those days. My days......
@MrGoogelaar11 ай бұрын
At first glance that blower motor 0:29 looks like a turbo charger!
@davebdave1
11 ай бұрын
LOL
@LawnMowersThingsThatMakeNoise11 ай бұрын
please please please resto it !! and do a vlog
@davebdave1
11 ай бұрын
It might take awhile but we will restore it.
@hlaokaboutfightiganimalstun Жыл бұрын
Very very good too good Morris car .❤❤❤❤❤❤❤❤❤❤❤❤❤❤😊😊..။။
@KiwiCatherineJemma Жыл бұрын
RADIATOR CAP info..., yes be sure to use the correct Pressure rating. The oldest Morris Minors, the Sidevalve engine models from the late 1940's and early 1950's were ZERO pounds pressure rated, ie it was just a Steam Venting cap. It had no spring, just some zigzag sorta holes to stop water sloshing out on corners. It worked without a waterpump but the radiator had a large top tank and contained from memory 14 litres, about 14 US quarts of coolant. Later British cars, such as the later Overhead valve Morris Minors, 850cc, 1,000cc and 1100cc had either 4 psi or perhaps 7psi radiator caps. Yes you are better using the original old Radiator cap at first. Find out what that model was supposed to have and buy a new correct one if needed. Over the years, cars' cooling systems have run at increasingly higher pressures. I saw a neighbour blow the radiator up is his Morris Minor (sidevalve, unpressurised) and then complain that Morris-es had bad radiators and always blew up their radiators. He was running a pressure cap on it ! LOL Great to see a Morris Minor on the other side of the world, even if your steering wheel is on the wrong side of the car. cheerio xx
@davebdave1
Жыл бұрын
Thanks, Interesting that the flatheads didn’t have a water pump
@KiwiCatherineJemma
Жыл бұрын
@@davebdave1 Yes the cooling system operated totally by "thermosyphon" only whereby the hotter water rose and cooler water sank. So no heater option was available on the (918cc) sidevalve engined cars. Heaters became available, (often on British cars of the era as an "extra cost option") on later Morris Minor cars with overhead valve engines (850cc, 1,000cc and 1,100cc etc), and, crucially, that engine design always had a waterpump. Without a typical waterpump to bolt the radiator fan blade onto, I seem to recall the fan blade being bolted directly to the generator pulley, (on the sidevalve early model Morris Minors). New Zealand had primarily British made cars (before the later Japanese car invasion, 1970's onwards) I'm of the generation that Morris Minors were getting old enough and therefore cheap enough, that for many of us, it was the cars we learned to drive in, or buy as affordable to a teenager or first car, and subsequently learnt to repair.
@benjaminconstant6930 Жыл бұрын
Este carburador deste carro ai e o mesmo do dodge pó para e o motor parece muito com o motor do fortinho 18oo ou polara
@williamduncan56792 ай бұрын
Member lads firing order is 1342.😂
@neumoi332411 ай бұрын
It is far too gone. Restoration will cost a whistle. But I’d like to see it if you decide to.
@davebdave1
11 ай бұрын
Thanks, next time I’m in Florida Dan and I are going to inspect the underside of the car and come up with a plan. The car has been in our family since 1970 so we want to save it.
@damian-7953 ай бұрын
I am guessing there is no working clutch 😂😂
@benjaminconstant6930 Жыл бұрын
Este carburador deste carro ai e o mesmo do dodge pó para
@mariograca23211 ай бұрын
😂😂🎉🎉❤ carro 🚗 🤩
@enzorizzo311610 ай бұрын
Oo
@MrShobar11 ай бұрын
Whitworth tools, or metric?
@davebdave1
11 ай бұрын
Whatever fits but mostly SAE. I have some Whitworth but we didn’t need them. I think Whitworth fasteners are mostly used for the body panels.
@MrShobar
11 ай бұрын
@@davebdave1 My mom and dad had a 1952 Morris Minor that they bought new from a dealer. We probably used that car for more than fifteen years.
Пікірлер: 168
Reminds me of when l was a teen tackling these old type motors... We had no training just a little bit of nouse and learn as you go.. Those engines were so simple compared to the modern day engines .. Today ' you lift the bonnet take one look then shut it up again... l once pulled a motor out of a Holden Gemini ' reconditioned it and put it back in again , thats how user friendly they were back then.. im now 78 years old..
They were a classic of their time, a very unique sound from that 1 litre engine. Great video.
@davebdave1
Жыл бұрын
Thanks, I love the engine note combined with that first gear whine
My first car was a 1959 Morris Minor. At age 16 I learned a lot about cars with that model. Required vegetable-based brake fluid, proper installation of front wheel bearings, desirability of synchromesh in 1st gear, necessity of damping oil in SU carbs, proper centering of jets in SU carbs, desirability of decent oil cooler in California and/or cross-country trips, ineffectiveness of low-compression pistons, downside of shaving the flywheel (ring gear eats a hole in the oil pump), non-necessity of turn signals as standard equipment . . . I could go on, but I think I’ll stop here, I think you get the picture.
Thanks to you guys for givin her a second chance.. ❤❤❤
Those engines, not actually Morris, but Austin, 3-bearing crankshaft, pushrod valve operation were still in production until the year 2000, although unrefined, "tappity" they had a hard to beat combination of drivability in a wide torque curve and low fuel-consumption, Harry Weslake was the engineer behind the cylinder head which gave these engines those characteristics. Another aspect, even after high mileage, they were good first time starters in all weathers, deep winter or high summer, something which the equivalent engine from Ford could not match
@laing685
Жыл бұрын
thanks for showing it was a bit like back to the future lol i enjoyed it
Did everything in a Morris minor .would pull the car over onto a square bale and change the clutch. I think I did it all with a 1/2 inch And 9/16 spanner. Owned 5 in the day still wish I had the traveller. Brakes were terrible the shaft would seize under the floor Matt and the cylinders would seize. But the engine would always start with the starting handle. Simple car. No fancy electronics. Loved them.
Love old cars like this with the old style engines and S.U Carbs they are such a pleasure to work on just like the vw bug so easy to pop the engines out ,thanks for the upload it was a pleasure to watch.
OH WOW!!!! I am so happy to see this kind of video!!!! This reminds me of when I first got my 1960 Morris Mini!!! I had so much fun getting that tiny car Road worthy again!!! My neighbors even asked if they could ride along on test drives!!! ❤😊😁
@davebdave1
Жыл бұрын
Thanks I’m not sure when the Morris will be roadworthy again but I’m already planning the launch party.
@redmann31567
Жыл бұрын
I will definitely watch your videos, notifications on sir!!!!
Lol, I didn't read the description and thought it was a Beetle. Trying to figure out who put a vertical 4cyl in It. Too funny
I love the Morris minor
Damn! I'm 74 years-old and I haven't seen a Morris Minor in years! In fact, I had forgotten all about them.
@TheGreatest1974
5 ай бұрын
Apparently there are still 30,000 of them on British roads?! Yes- amazing eh? There’s a few places in England that all they do is Morris minor parts & repairs. Any part you want you can get. Other places concentrate on restoring them to pristine condition. Great eh? I’m 53 and I would LOVE one but I can’t afford one, although you can get one running well needing a little weld here and there for £2,000. But restored to better than new with a Morris 1275cc engine in it is up to £30,000!
I'm in New Zealand. Morris Minor is a Classic icon. In the '60s there were thousands on the road in NZ. Japan copied this reliable OHV motor for the first Datsuns produced post WW2. Early series were side valve, then moved to OHV (1954??) Humourous watching US car shows repairing old pommy cars. 😂 Great watch. Cheers
My high school English teacher had a slightly older convertible (drophead?). I watched him enter the building soaking wet as the top leaked if a passerby spit on the sidewalk. The final straw came while he was proceeding up a small local hill and being passed by a vespa (not the prayer). Narragansett Bay
@davebdave1
Жыл бұрын
LOL, as Dan said they are great on Florida flatland, I’m not sure how it would do on a hill as I’ve never driven it up one. This does have the bigger 1098cc engine.
@PeterShaw-lb9lt
Жыл бұрын
Are you guys getting desperate working on English cars I worked on to many here in Australia they were very common and a pain to do anything too
I have a 1952 Morris minor 4 door side valve Engine with Dashpot front suspension system , leaf spring rear suspension. Not in working condition for over 15 years it gave me excellent service . Now parts availability is problem
Love seeing old bits of kit being bought back to life!. 🤣 Nice one!. Nuff said!. 🙂
Lovely to see it running, and great memories. I fear that with so much rust it might be the last time 😢
@davebdave1
3 ай бұрын
Thanks, It won’t be anytime soon but I’m confident we’ll get it on the road again. I do think I need to hurry up and buy the replacement metal while it is still available.
@pedrokd5439
2 ай бұрын
Morris minor spares in the UK have every part for rebuilding an MM.
Complimenti..buona per la vostra passione..bel modello di auto...operazione di recupero all'altezza delle aspettative. 😊
An unmistakable sound from the old peashooter exhaust ❤
Lucky the thermostat housing wasn't corroded to the block and the studs ! If I remember correctly, when you get to the master cylinders under the floor you'll find some of the nuts/bolts are 1/4 Whitworth..... does get more old school than that !
Had a 1966 saloon,sold it to a guy who said he was going to finish the restoration off,he didn't.Instead he scrapped it!!!
@davebdave1
11 ай бұрын
That’s a bummer. They are fairly rare here in the U.S.
i had a 1952 flthead lhd ....i miss it... the back seat was well used during thye hippy '60's...[nudge/nudge]
You can get nearly every part you need still for the "Moggy" in the UK. And reasonably priced as theres a huge following for them still. As a rare care in the States it would be well worth restoring. They are actually quite a smooth car on the road, fast they isn't by todays standards but a simple piece of car to keep in the road.
@davebdave1
Жыл бұрын
I’ll see a Morris at the larger car shows but I haven’t seen one out on the road in years. There are a few parts suppliers here in the States so I’m confident we can save it.
My father had a Seriies V Traveller in which we had a memorable holiday around 1970 camping in France, Switzerland and Italy. Rather later in the '70s we had a 2-door Series III as the family car. Dad bought it for Mum to drive and my brother and I to learn on. The deal was that Dad put up the purchase price and that was it, we had to service and repair it ourselves with Dad's tutelage if required. They had weak 1st/reverse gears and we had to change 2 or 3 gearboxes sourced from the scrap yard. We eventually came across a unused Gold Seal (BMC refurbished) gearbox and that was the last one we fitted. We were pretty adept at whipping out the front seats, taking up the part of the floor covering the gearbox/clutch and swapping the gearbox, a Sunday morning job. The brakes were a pain as the wheel cylinders seemed to seize on a whim and always needed changing for the MOT. Dad's insistence on us maintaining repairing it is principally what has enabled me to maintain my own cars over the years up to and including our current BMW E39s. As teenagers we had ideas about dropping Midget brakes and engine into it but this remained a pipe dream. My first car was Series V Moggie 1000, given to me by my grand-father when he gave up driving. It didn't last long. In common with most BMCs at the time the tin-worm was quietly chewing away at the floor and sills. It was his 2nd Moggie. He had a Series III that he had traded in for an 1100. The 1100 never did find favour with him and with some expensive rust repairs required on what was a nearly new car he got shot of it and bought the Series V. His brother's one and only car was a Series II convertible, it would be worth a bob or two these days.
@davebdave1
Жыл бұрын
I had forgotten but we did replace the gearbox at some point. I don’t know where my Dad found it.
My first car was a 56 Tourer top,driving around I started to morries stopped on the side of road with front wheel at 90 degrees to normal.Jacked mine up to have check.....rusted out frames seemed to a common thing !!!
Beautiful colour
@davebdave1
Жыл бұрын
Thanks, my grandfather painted it for me in 1986.
@nygelmiller5293
Жыл бұрын
@@davebdave1 now you just need to emphasize the w h e e l s and grille bars, by painting them the whitest of white. (I think they ARE white, but getting a bit yellow, like an old tennis shoe! The factory colour is sort of cream, and hideously old fashioned!
@nygelmiller5293
Жыл бұрын
I didn't own one of these myself, but, like everyone else in the U.K., I have been IN these cars . After all, they were the first million selling car in the U.K.!
Brilliant video.
@davebdave1
11 ай бұрын
Thanks
Seen many of these Morris Minors in India and WOW they were terrific. But yes this is a first, a single door and a Left Hand Drive.
@hannetjiescheepers9819
Жыл бұрын
How must it Run You Doos It has no feet (POES KOP)
well done getting that old thing going, and doubly well done for getting anywhere without a clutch! greetings from a fellow moggie owner in england, best of luck getting that motor sorted 👍
@davebdave1
Жыл бұрын
Thanks, just the beginning of a long journey to get it back on the road. They really are fun cars
@SunofYork
Жыл бұрын
I had two of these in the early seventies. The suspension collapsed on reverse in the police station parking lot ! It is a 'torsion bar' suspension and it whipped the bottle jack up past my ear ...almost killed me.... I had a long history with A type engines...(A35 Van , minis, Farina A40) then B type in a Marina rot box... I LOVE Toyotas nowadays. I have zero nostalgia for those days... British cars and bikes were crap compared today's Jap cars.. ...eg Kawasaki 1000Sx bikes ... I only spent 59 years in England then left
Love it! The little engine that could 😊
Grew up with a Morris Minor. We stuffed 11 people into it when visiting relatives, just a bit cramped. My first car was a Morris Oxford. At the time, I didn't appreciate either one of them. Went on to an assortment of British sports cars, including hill climbing a Spitfire. Miss all those relatively crude cars.
@davebdave1
Жыл бұрын
LOL, It was common for me to have 6 or 7 in the Morris driving friends home after school, but never 11.
Love ❤ this little 2door car!!
CLUTCH SEIZED INFO... Previously the following has worked for me...warm up the engine in neutral. Then switch off. Then select first gear, (or reverse), and start the engine. The car will lurch and start driving forward (or backward). Remember this is decades before those silly new safety laws about "foot on the clutch to activate starter", (none of my cars have EVER had that). Now as you drive the car around the yard in first/reverse accelerate and deccelerate in a jerky fashion. This will often enable a stuck clutch to become free. Job Done !
We owned four of these moris minors at one time they were all great looking cars, ran and drove like champs. Loved them we were told that only 75 of them made it to the USA!! I know where 2 are here one convertible and one is a woodies wagon garage kept and never sold!!
my Brazilian Air force mechanic father,had a Morris 😁
Oil in the dash pot will improve the operation of the SU carburettor. Not sure that red engine is a factory rebuild. Here in the UK at least, factory rebuilds were "Gold Seal" and painted accordingly. From memory, and it is about 50 years ago now, rebuilt units didn't come with ancillaries (manifolds etc) so wouldn't have been painted in the same colour as the block/head.
@davebdave1
Жыл бұрын
I don’t remember where my dad found the engine but my memory tells me it might have been silver. I think I painted it red with leftover pint used for a Chevrolet engine. Next time we work on it I’ll scrape off some red and see what’s underneath.
@grahamepigney8565
Жыл бұрын
@@davebdave1 if I recall correctly you can tell the origins of the engine (capacity, type of vehicle...) from the prefix of the serial number on the block and a factory remanufactured engine will have its own prefix. I think I've got some documentation around here somewhere. If you let me know what the first 4 characters of the serial number are I can probably check them.
Nothing could be worse than the fear that one had given up too soon, and left one unexpended effort that might have saved the world.
Ive owned 2 of em...that engine is basically an upgraded mini engine
@ukuleletyke
9 ай бұрын
The Minor came first, and before that, it was, I think, the old Austin A30 engine. So the Mini got an upgraded A30 engine, with a gearbox in the sump.
Nice t9 see that you got the Morris Minor Is moving even with some help, nice to see that the Morris still has the manual start up method in the front like most cars had way back in the day.
@davebdave1
Жыл бұрын
Thanks, I used to crank start it just for fun. People would see me start it and tell me about their early cars.
I have my grandpas Morris Minor. Its in way worse shape but I got it to run after 45 years of sitting.
@davidwhitman9609
Жыл бұрын
That’s excellent! They are amazing cars.
Excellent job done. My escot tractor is not is use for 10 yrs will it work now, if ys what important to check.
Amazing 😂 you guys are hilarious Great piece Was my first car too 😅
@davebdave1
9 ай бұрын
Thanks! It’s an excellent first car!
em sao paulo anos 60 ate inicio dos anos 70 so tinha este modelo de veiculo nao encontrava outro
Summer of Love reg. That back seat was busy ha
The clutch pedal, and the brake pedal, pivot on a shaft at about floor level, it’s quite possibly that it has seized on that shaft
My feverit car
This car smartened could be a nice looking car. I once saw the rival to this car, the Austin A30/A35, in exactly the same shade of metallic blue.( silvery metallic blue). A non- factory finish. It occurred to me that METALLIC finishes particularly suit such curvy cars. In the metallic colours, you see a light and shade effect on the curves! Also, the smaller lights under the headlights look particularly nice, because they MATCH the headlights. Unlike in the U.K., where the small lights are ORANGE/WHITE FOR THE TURN signals/ running lights.
@davebdave1
Жыл бұрын
Thanks, My grandfather convinced me that it would be the best color for the car. He also painted it for me in 1986
That was great fellas.
@davebdave1
11 ай бұрын
Thanks!
Lovely little cars
Di takengon aceh tengah di masa aku kecil di tahun 1970 banyak mobil sedan morrys ,chevrolet ,willys ,jeep ,impala, toyoved, jeep, jazz mobil rusia,gmc ,dodge, layland,nissan patrol,disini angkut penumpang dari kampung kedaerah kota lain ,
My long time late Grandfather had two of these, the last from 1959 (The former needed new tires, and he came home with a new car, a new model 1000, a little scared for my Grandmothers reaction!). I think he had to lock it from the passenger side (Denmark)? In its heated store room it had blankets for protection on top, and if rain, my Grandmother had to use a bicycle! My Grandfather himself could laugh from this, but it wasn't used during rain, unless unlucky to happen while driving!!!
@davebdave1
Жыл бұрын
I love this story, I would like to have met your Grandfather. This Morris had a different life. It sat outside in Hurricanes and was driven in rain so heavy the windshield wipers couldn’t keep up.
It looks like the colour was originally smoke grey, which eas in reality, a light blue. I have a 1966 4 door in store here in the UK, which comes out in the summer.
@davebdave1
Жыл бұрын
Thanks, I didn’t know the name for the original color.
..and the thing about Morries, is they only need one tool, genius British design..12lb Hammer..
Your Minor has the ribbed case gearbox, which is far better than earlier smooth case... It should also have the 1098cc engine - a mighty 48 Bhp
Very good , fantastic ,,,,
@davebdave1
Жыл бұрын
Thanks!
نہایت ہی خوب Very lovely car, these cars was used in Pakistan as a taxi
Good job
Selain morrys ,di masa tahun 1970,ada juga kulihat di takengon mobil land loverd ,vw volg wagen,fiat sedan renauld ,mazda .
Save the old girl....Every part available ...lovely old cars...i have one here in uk...👍👍👍
Incredible video😊
@davebdave1
6 ай бұрын
Thank you!
I had one in Trinidad
Dave, glad to see you’re still wrenching on stuff pretty cool stuff here
@davidwhitman9609
Жыл бұрын
Thanks Rob! I’ve got project cars spread all over, just not enough spare time to finish them. It’s fun working with my nephew Dan although he’s got even less free time to work on his stuff, LOL.
@robertswanson5269
Жыл бұрын
@@davidwhitman9609 that’s what it’s all about!
Lucas makes excellent points, shame the same cant be said for his last film
@davebdave1
9 ай бұрын
Lol
That A series engine was just about bullet proof
Radio looks pretty good
@davebdave1
Жыл бұрын
LOL, I mounted it to a wood panel to isolate from the Chasis which is Positive ground. I spent some time making sure everything was isolated from the car’s metal but that was before the internet. I now know that I could have just switched the battery to negative ground and re-polarized the generator in a matter of minutes.
@davidgreenwood5241
Жыл бұрын
@@davebdave1 ye even before cd that one
Very good Morris miner .❤❤❤❤❤❤❤.။။
Criminal! Not cricket! Left hand drive. Oh the pain, the pain.
@nygelmiller5293
Жыл бұрын
Left hand drive? On the other hand, a good selling EXPORT car!
I thought any Moggies in the states wouldn't rot like they do here
Made by the British Motor Corporation ( which included Austin, Morris & MG) in the year before they merged with Leyland ( which included Rover, Triumph & Jaguar) to become British Leyland. One of the major problems was that the marques continued to see each other as rivals every time there was a merger - even though they were part of the same company. This could lead to bad decisions being made eg the Triumph Stag engine could have had a much better Rover engine, but Triumph went for a poorer modification of one of their engines. Sad, because some of the products such as the Morris Minor were fantastic!
More morris content plz! If u can fix the rusty framing that would be good 😂
@davebdave1
Жыл бұрын
Thanks, The Frame is our next priority
That block needs a CLR treatment 😮
@davebdave1
Жыл бұрын
Yes, the cooling passages are bad. We are going to do some more cleaning as I’m worried about hot spots around the cylinders. Might try CLR
Great little cars, have you managed to repair the clutch yet?
@davebdave1
11 ай бұрын
Haven’t had a chance to work on it. We’ll post a video when we do, hopefully soon.
Why do you use your wrench’s backwards?
Bit strange seeing one of these with left hand drive.
Take a scaper push it in between the clutch and flywheel
14:03 😂
❤
it should be a 1098CC engine lol not that 98cc makes much difference but i have owned one myself and they are a hoot to drive 🙂
Those old British classics have engines that can go on an on not like the newer cars where even the simplest thing can ruin a car.
@davebdave1
Жыл бұрын
If it weren’t for the rust it would already be back in service. The remaining mechanical problems are minor
My first Car, Paid $70.00 for it. Drove it aroun,d, illegally of course cos I didn't have a license, The I got my call up and it sat outside my mum's house for about eleven months while i was away. Came home on leave, got my license, then traded it for a red Escort, got $200.00 . good car , windows taped up cos the winders didn't work. Rust holes in the floor, but you couldn,t stop it.
"what is wrong ...with this car...? thanks , i enjoyed your video
Lucas electrical system = Prince of Darkness
@davebdave1
Жыл бұрын
LOL, I’ve heard that but I never had any electric issues in the Morris except for the SU fuel pump randomly quitting until I rapped on it with a screwdriver.
@narrowbeamdaydream
11 ай бұрын
@@davebdave1 The SU fuel pump was not made by Lucas
Sweeeeet !
Once it's fixed is it better than the classic VW Beetle?
@davebdave1
11 ай бұрын
I think it is but Bugs are cool too.
You know when the postman was about in minor by the sound
Can I get one in Ontario canada
I like it morees
33k views in 6 days.!?
Will it run and drive???? Of course it will. cars were built properly in those days. My days......
At first glance that blower motor 0:29 looks like a turbo charger!
@davebdave1
11 ай бұрын
LOL
please please please resto it !! and do a vlog
@davebdave1
11 ай бұрын
It might take awhile but we will restore it.
Very very good too good Morris car .❤❤❤❤❤❤❤❤❤❤❤❤❤❤😊😊..။။
RADIATOR CAP info..., yes be sure to use the correct Pressure rating. The oldest Morris Minors, the Sidevalve engine models from the late 1940's and early 1950's were ZERO pounds pressure rated, ie it was just a Steam Venting cap. It had no spring, just some zigzag sorta holes to stop water sloshing out on corners. It worked without a waterpump but the radiator had a large top tank and contained from memory 14 litres, about 14 US quarts of coolant. Later British cars, such as the later Overhead valve Morris Minors, 850cc, 1,000cc and 1100cc had either 4 psi or perhaps 7psi radiator caps. Yes you are better using the original old Radiator cap at first. Find out what that model was supposed to have and buy a new correct one if needed. Over the years, cars' cooling systems have run at increasingly higher pressures. I saw a neighbour blow the radiator up is his Morris Minor (sidevalve, unpressurised) and then complain that Morris-es had bad radiators and always blew up their radiators. He was running a pressure cap on it ! LOL Great to see a Morris Minor on the other side of the world, even if your steering wheel is on the wrong side of the car. cheerio xx
@davebdave1
Жыл бұрын
Thanks, Interesting that the flatheads didn’t have a water pump
@KiwiCatherineJemma
Жыл бұрын
@@davebdave1 Yes the cooling system operated totally by "thermosyphon" only whereby the hotter water rose and cooler water sank. So no heater option was available on the (918cc) sidevalve engined cars. Heaters became available, (often on British cars of the era as an "extra cost option") on later Morris Minor cars with overhead valve engines (850cc, 1,000cc and 1,100cc etc), and, crucially, that engine design always had a waterpump. Without a typical waterpump to bolt the radiator fan blade onto, I seem to recall the fan blade being bolted directly to the generator pulley, (on the sidevalve early model Morris Minors). New Zealand had primarily British made cars (before the later Japanese car invasion, 1970's onwards) I'm of the generation that Morris Minors were getting old enough and therefore cheap enough, that for many of us, it was the cars we learned to drive in, or buy as affordable to a teenager or first car, and subsequently learnt to repair.
Este carburador deste carro ai e o mesmo do dodge pó para e o motor parece muito com o motor do fortinho 18oo ou polara
Member lads firing order is 1342.😂
It is far too gone. Restoration will cost a whistle. But I’d like to see it if you decide to.
@davebdave1
11 ай бұрын
Thanks, next time I’m in Florida Dan and I are going to inspect the underside of the car and come up with a plan. The car has been in our family since 1970 so we want to save it.
I am guessing there is no working clutch 😂😂
Este carburador deste carro ai e o mesmo do dodge pó para
😂😂🎉🎉❤ carro 🚗 🤩
Oo
Whitworth tools, or metric?
@davebdave1
11 ай бұрын
Whatever fits but mostly SAE. I have some Whitworth but we didn’t need them. I think Whitworth fasteners are mostly used for the body panels.
@MrShobar
11 ай бұрын
@@davebdave1 My mom and dad had a 1952 Morris Minor that they bought new from a dealer. We probably used that car for more than fifteen years.