VW Alltrack 50K Service| Rear Diff, Bevel Box, Manual Trans Fluid, Brake Flush, Spark Plugs, Oil
Автокөліктер мен көлік құралдары
In this episode of TheFadShow I perform the 50k service on my MK7.5 VW Golf Alltrack. I change the rear differential fluid, front beval box fluid, manual transmission fluid, brake fluid, spark plugs and engine oil. I show how to fill the transmission fluid with no fill plug.
~dom.ferr.90
Пікірлер: 29
Hey. I’ve really been enjoying your content. I just purchased a 19 SEL manual, so it’s all been pretty relatable. Good work.
In a pinch, when not replacing the copper crush washers, you should aneal them. This way they will seal like new. A common way is to suspend with a piece of steel wire and heat to a dull red with a propane torch, and then drop it into water. The washers on the VW plugs don't come off easily though.
Hey I just brought my 19" 6MT Alltrack into VW to swap the Manual Trans fluid. I DID NOT have the fill plug underneath the car BUT the tech filled the fluid up under the hood with a funnel VERY easily and said it wasn't hard to get to. I think it's worth a look for you to find the fill plug for next time. They said it was like 2.13L to spec but I had them fill it to 2.3L. Either way, awesome watching your vids! Keep it up
Great video man keep it up! "Like a Stone" playing - I see you've got great taste in music too! RIP Chris !
@zamaller
Жыл бұрын
Also how do I know if I have the drain plug for my transmission? Is there a way to look it up by VIN?
Dude love the content. I have a 19 SE 6MT right around 30k. Long time diyer that's been hands off with this car but might follow this. I got an Audi B5 s4 avant manual i gotta get going again lol
Very helpful! Thanks
@thefadshow
Жыл бұрын
Thank you!
In 2018, there was a stop sell order here in Canada because of the brakes. I think it was related to the bleed screws.
This video helped out since I couldn't find much info for a 2020 GTI. It looks like the fill for the transmission fluid is same as the Alltrack, so I'll be using this video for reference when it's time. Did you set the selector shaft to neutral when doing the transmission fluid? One thing to note, looking at VW's documentation, they recommend a 18mm OD tube to fill the transmission. You might have been struggling since that tube is too small for the fluid. Thank you.
Do you have a parts list for service?
Did you put the car in neutral when you undid the "19mm shifter mechanism detent spring" bolt?
I do not see the link for the service schedule? Can you repost?
wo genau befindet sich die öleinfüllschraube beim Getriebe? habe nichts gefunden?
Well done! Could you note the tube size that you used that fits in the fill holes on the rear diff and bevel box? I bought a cheap hand pump off Amazon and the tube was too big. Ended up shoving a piece of smaller tubing from the hardware store inside it to fit in the hole. Also, agreed on the rear diff. Spec says that it takes 900 ml, which is what I got out of it... but when I filled it, it took the whole liter and didn't overflow. Glad you got the manual trans. Haven't seen a video of that, only pictures.
@thefadshow
Жыл бұрын
Here is a link to what I got on Amazon. It says it has a 4mm diameter. Large 100ml Plastic Syringe with Tubing, Carejoy Indutrial Syringes + 80cm(31.5in) Handy Long Hose Fluid Suction Injector for Scientific Labs Injecting, Feeding Pets, Drawing Oil, Fluid and Water a.co/d/4F1xdiR
@BenNawrath
Жыл бұрын
@@thefadshow I use syringes like this for dosing out fertilizer in my sprayer for the lawn lol. Handy things to have around,.
Why do you not warm up your new fluids? Those bags are super easy to do by just dropping in a bucket of hot water for like 30 minutes before....
Great video. I have the same vehicle, but in red. What do you use to raise your vehicle?
@thefadshow
Жыл бұрын
Quick Jacks
Great video and thanks for posting! As an owner of a 2019 Golf 1.4 L and a 2022 Tiguan SE R Line, I plan on doing the same maintaining care that you do on your vehicles. Q: how much do you think you saved in VW labor cost by doing the whole thing yourself!
@thefadshow
Жыл бұрын
My guess is VW would charge probably 6 hours of labor for all of this work. Labor rate depends on area but 100-140 an hour.
@grimepatrol970
6 ай бұрын
@@thefadshow VW in ontario offers Haldex at $139.99 CAD at a 30% promotion. Not sure on the other stuff other than the manual trans fluid which most of your cost is the 3 bottles of Fluid. I was over $500 CAD for this service last week.
Tell me more about this lack of fill plug BS. For reals? I’m about to do all this and that is lame!
nice video, i dont get mechanics doing work with their big ass watches on. Silly
You are using the wrong rear diff oil.
@thefadshow
Жыл бұрын
The rear diff uses two different fluids one for the Haldex clutch and one for the differential itself. In this video I am servicing the diff and using the correct fluid.
@bradleygray2103
3 ай бұрын
GL5 75w-90 for rear differential and front bevel box. Haldex fluid for Haldex.