How to Test IGBT Bricks - DMM Test & Lamp Test
How to Test IGBT Brick Modules with a Multimeter (DMM) and test IGBTs with a Lamp & Battery. www.kevingitte...
How to Solve a Rubik’s Cube: • How To Solve Rubik's C...
IGBT Test with the Digital Multimeter is useful when the IGBT module cannot easily be removed or isolated.
Lamp & Battery test for when the IGBT can be removed or isolated.
See end of video for diagrams.
Click here to Subscribe: goo.gl/DDfVab
How to Solve Rubik’s Cube Easy Tutorial:
• How To Solve Rubik's C...
www.kevingitte...
Some handy test equipment and tools:
Handheld LCR Meter Der De-5000: amzn.to/2yQxFa2
Drok Electronics Component Transistor Tester: amzn.to/2tRTFeS
Multifunction Meter DIY Kit tester: amzn.to/2KvanIk
Atlas DCA55 Semiconductor Tester: amzn.to/2MC395F
Peak Electronic Design: amzn.to/2KujjgZ
Fluke 177 Multimeter: amzn.to/2tPtS7b
Fluke 62 IR Thermometer: amzn.to/2tDDrac
Bench Power Supply 0-50vdc: amzn.to/2yWir3s
Wera Kraftform 70 32 Piece Set: amzn.to/2MBZXqH
Wera Kraftform Compact 25: amzn.to/2IE6DSO
Like, Subscribe & Check out other videos:
Magnetism: goo.gl/Pk8dV0
Electrical Electronics: goo.gl/E3oIKn
LEDs: goo.gl/3rbfRf
Science / Education: goo.gl/iAe7EM
IGBT Battery Lamp Test:
- Wire lamp in series with 12v battery and IGBT polarity respective.
Negative of battery to E, Positive of battery to lamp, other side of lamp to C.
- Touch positive of battery and gate to turn on.
- Touch negative of battery and gate to turn off.
* Note touch battery first as IBGTs are ESD sensitive and can be damaged.
IGBT Digital Multimeter (DMM) Test Procedure:
Collector-Emitter Junction test:
- With the module out of circuit remove the conductive foam and short the gate to emitter.
- With DMM in diode check mode, the collector to emitter should give a normal diode reading with positive on the emitter and negative on the collector.
- The DMM should read open or infinite with positive on the collector and negative on the emitter. Damaged IGBTs may test as shorted in both positive and negative directions, open in both directions, or resistive in both directions.
Gate test: With the DMM in resistance mode the resistance from gate to collector and gate to emitter should read infinite on a good device. A damaged device may be shorted or have resistive leakage from gate to collector and/or emitter.
IGBT Brick Lamp Test,
IGBT Brick Multimeter Test,
Пікірлер: 77
www.KevinGittemeier.com Shop Electronic Test Equipment amzn.to/2NfwhQQ & Electronic Kits amzn.to/2NRr9n2 (Amazon Affiliate)
@KTFG
5 жыл бұрын
The simple method Emily used to solve Rubik’s Cube at 3 years old: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
@KTFG
5 жыл бұрын
How Emily solved Rubik's 2x2 at 3 years old. How To Solve 2x2 Rubik's Cube: So Easy A 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html
@KTFG
4 жыл бұрын
How To Solve Rubik’s Cube: So Easy a 3 Year Old Can Do It: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html How to Solve Rubik’s 2x2: So Easy a 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html How To Solve 2x2 Rubik’s Cube Part 2: Intermediate Method kzread.info/dash/bejne/mHia0sx8Xaq2crA.html 2x2 and 3x3 Intermediate Method 2 Look OLLs & PLLs
How To Solve Rubik’s Cube: So Easy a 3 Year Old Can Do It: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html How to Solve Rubik’s 2x2: So Easy a 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html How To Solve 2x2 Rubik’s Cube Part 2: Intermediate Method kzread.info/dash/bejne/mHia0sx8Xaq2crA.html 2x2 and 3x3 Intermediate Method 2 Look OLLs & PLLs
@KTFG
4 жыл бұрын
2020 Race: kzread.info/dash/bejne/gKaaqcizc9S3aNY.html www.kevingittemeier.com www.amazon.com/shop/kevingittemeier
@KTFG
4 жыл бұрын
Megaminx Giveaway: Megaminx Last Layer Tutorial is finished: kzread.info/dash/bejne/pWV6sNmfdsfYhLA.html Solve Megaminx Last Layer in 4 Steps with only 3 Algorithms Help us get to 100k Subscribers: goo.gl/DDfVab www.kevingittemeier.com
How Emily solved Rubik's 2x2 at 3 years old. How To Solve 2x2 Rubik's Cube: So Easy A 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html
@KTFG
4 жыл бұрын
Gan 354 M 3x3: amzn.to/31WMCBG Gan Magnetic Megaminx: amzn.to/30Z4TwX Gan 2x2 Magnetic Speed Cube: amzn.to/313BUbn Look for upcoming Megaminx and Pyraminx Tutorials. I just placed an order for 10 Megaminxs and 5 Pyraminxs so I can peel of stickers to better illustrate the steps. www.kevingittemeier.com Amazon Affiliate Links
@KTFG
4 жыл бұрын
Megaminx Giveaway: Megaminx Last Layer Tutorial is finished: kzread.info/dash/bejne/pWV6sNmfdsfYhLA.html Solve Megaminx Last Layer in 4 Steps with only 3 Algorithms Help us get to 100k Subscribers: goo.gl/DDfVab www.kevingittemeier.com
How to test IPM IGBTs: kzread.info/dash/bejne/epWqsaOHc5fSkrQ.html
@KTFG
5 жыл бұрын
How to Solve Rubik’s Cube Easy Tutorial: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
@KTFG
5 жыл бұрын
How Emily solved Rubik's 2x2 at 3 years old. How To Solve 2x2 Rubik's Cube: So Easy A 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html
Megaminx Giveaway: Megaminx Last Layer Tutorial is finished: kzread.info/dash/bejne/pWV6sNmfdsfYhLA.html Solve Megaminx Last Layer in 4 Steps with only 3 Algorithms Help us get to 100k Subscribers: goo.gl/DDfVab www.kevingittemeier.com
The simple method Emily used to solve Rubik’s Cube at 3 years old: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
@KTFG
5 жыл бұрын
How to Solve Rubik’s Cube Easy Tutorial: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
@KTFG
5 жыл бұрын
How Emily solved Rubik's 2x2 at 3 years old. How To Solve 2x2 Rubik's Cube: So Easy A 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html
Absolutely love this didn’t think to use this as a unique learning experience. Cool video man.
@KTFG
Ай бұрын
Glad you liked it!
Very good vlog !!!!
Thanks!
@KTFG
2 жыл бұрын
No problem, more here: www.kevingittemeier.com/?s=IGBT
Красавчик. Всё ясно, и без лишней воды.
@KTFG
5 жыл бұрын
How to Solve Rubik’s Cube Easy Tutorial: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
@KTFG
5 жыл бұрын
How Emily solved Rubik's 2x2 at 3 years old. How To Solve 2x2 Rubik's Cube: So Easy A 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html
Hi I've the same igbt from infineon technologies. At pin 4,5 and 6,7 two igbt gives values on diode mode. But one is not giving any values on that pins. Which one is faulty from these modules?
Please tell me, when checking the device, my modules seem to be intact, but when testing with a lamp, they open with a positive bias on the shutter and the lamp ignites, and if you remove the bias, they immediately close without holding the collector-emitter transition in the open state, is this correct or not?
@KTFG
3 жыл бұрын
If I am understanding you correctly it sounds bad to me. An IGBT should stay on once triggered with + (positive) on gate and turn off when - (negative) applied to gate. It could be that you are not fully turning it on with enough voltage.
@francuahf
3 жыл бұрын
@@KTFG Dr. Kevin, Thanks for the answer. Yes, it is powerful and high-voltage is 2mbi150n-120, I am trying to test it at 30 volts, it switches, but does not hold itself in this state, so we have doubts about its integrity.
what size resistor are you using ???
@KTFG
3 жыл бұрын
I believe that was a 1,000 ohm resistor but anything between a few hundred and few thousands ohms should be fine depending on voltage used. The resistor is just to slow the rate of electrons flooding or leaving the gate. Keep in mind when just using your finger and no resistor a dry body is typically several hundred thousand Ohms. I’ll eventually put more info on my website: www.kevingittemeier.com
one thing i dont understan why with battery test the positive in colector and when diode test the positive of dmm in Emeter how current will pass againest diode direction in battery test
@KTFG
5 жыл бұрын
It doesn’t pass through the diode. It passes through the IGBT. The diode is just flyback
@mosalim7119
5 жыл бұрын
thanks for the replay and infos i have an igbt with a shorted gate dose that mean that the high voltage has passed throgh the low voltage driver circuit and mabe damaged it the circuit is protected with diodes and they are fine dose this mean the high voltage didnt pass or diodes do allow reverse current higher then their limit and still stay healthy thanks alot
Damn, someone has access to nice heatsinks. :)
@KTFG
3 жыл бұрын
Yes, they come in handy for many projects and even for cooling laptops and SSDs: www.kevingittemeier.com/editing-workstation/
Thanks you very much
@KTFG
5 жыл бұрын
How to Solve Rubik’s Cube Easy Tutorial: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
Thanks you for information and helping and safe money time thanks
@KTFG
6 жыл бұрын
+sheikh nouman Your welcome, we also did a video on testing IPM IGBTs (Intelligent Power Modules) kzread.info/dash/bejne/epWqsaOHc5fSkrQ.html
@user-tm5ce3dv1c
6 жыл бұрын
Output input voltage
@KTFG
6 жыл бұрын
+sheikh nouman 👍
@KTFG
5 жыл бұрын
How to Solve Rubik’s Cube Easy Tutorial: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
@KTFG
5 жыл бұрын
How Emily solved Rubik's 2x2 at 3 years old. How To Solve 2x2 Rubik's Cube: So Easy A 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html
Good I need to know how to measure IGBT card and repair/do maintanance on acs 850 driver vfd
@KTFG
5 жыл бұрын
How to Solve Rubik’s Cube Easy Tutorial: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
@KTFG
5 жыл бұрын
How Emily solved Rubik's 2x2 at 3 years old. How To Solve 2x2 Rubik's Cube: So Easy A 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html
what voltage triggers the gate tho?>
@KTFG
5 жыл бұрын
In this example we use the 12 volt battery & 9 volts from power supply to turn the IGBT On and Off by restoring electrons to the gate to turn it On (negative) or by stripping electrons from the gate to turn it off (positive). Check the data sheets of your IGBT for minimum and maximum gate voltage.
@KTFG
5 жыл бұрын
Also How to Solve a Rubik’s Cube so easy a 3 year old can do it: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html
@KTFG
5 жыл бұрын
How Emily solved Rubik's 2x2 at 3 years old. How To Solve 2x2 Rubik's Cube: So Easy A 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html
@KTFG
5 жыл бұрын
2x2 Rubik's Cube Beginner Tutorial How To Solve 2x2 Rubik's Cube: So Easy A 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html
мне помогло видео, спасибо!
learning igbt,,I want to know what emitter terminal and how it hooked
@KTFG
5 жыл бұрын
Download data sheet for the specific IGBT if necessary as seen in this video
@KTFG
5 жыл бұрын
How to Solve Rubik’s Cube Easy Tutorial: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
Excelent video.
@KTFG
8 жыл бұрын
+Teobaldo Monteagudo Thanks
@KTFG
5 жыл бұрын
How Emily solved Rubik's 2x2 at 3 years old. How To Solve 2x2 Rubik's Cube: So Easy A 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html
Here's an app for all your electrical needs! android.oms.apps.opera.com/en_us/circuit_breaker_vlite.html
Hi you tôi muốn xác định chân igbt tyco p084a2004 . Bạn có thể dúp tôi . Xin cảm ơn rất nhiều . I from vietnams
@KTFG
5 жыл бұрын
How to Solve Rubik’s Cube Easy Tutorial: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
@KTFG
5 жыл бұрын
How Emily solved Rubik's 2x2 at 3 years old. How To Solve 2x2 Rubik's Cube: So Easy A 3 Year Old Can Do It: kzread.info/dash/bejne/h413x9uuj9PIhKw.html
please. put. squemerick. electric. comple. plans.
@KTFG
5 жыл бұрын
How to Solve Rubik’s Cube Easy Tutorial: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
good technic
@KTFG
8 жыл бұрын
+Saleem Qazi TY
@saleemqazi44
8 жыл бұрын
hi
@saleemqazi44
8 жыл бұрын
how r u
mexico.
@KTFG
5 жыл бұрын
How to Solve Rubik’s Cube Easy Tutorial: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/
amir ail
@KTFG
5 жыл бұрын
How to Solve Rubik’s Cube Easy Tutorial: kzread.info/dash/bejne/a6ekpql7lbrSYdI.html www.kevingittemeier.com/how-to-solve-rubiks-cube-easy/