How to replace thermostat, water outlet, and temperature sensor
This vehicle is a 2012 Hyundai i10 with 1.1L engine, automatic transmission.
Parts changed:
Water Outlet
Temperature Sensor
Thermostat
Labor hours: 2
Sharing how I replaced the parts through research and basic understanding on how each of the parts work. Special thanks to Hyundai i10 Club of the Philippines.
I noticed that upon after start-up and while engine is running at idle (neutral), while a/c off, radiator does not turn on when it reaches normal heat (approximately 8-10 minutes before fan turns on). It's nearly 20 mins. car still running idle, fan does not turn on. I also noticed that in heavy traffic, a/c blower weakens. Cold air weakens too. Engine humidity is so hot, you can feel the heat within .5m distance.
My own opinion of possible causes:
Busted fan fuse and/or radiator fan
Busted temperature sensor
Busted thermostat
Clogged radiator
Things I did prior to buying parts:
-Checked relays, checked fuses of fan, ac blower using multi meter. All are working.
-Checked radiator fan, working.
-Checked radiator cap, working.
-Checked hoses for any leaks, none.
Attention:
When refilling radiator coolant, always make sure engine is not hot. Do not open radiator cap while engine is hot. After initial refill and after engine is running idle, check water level again. Refill if needed.
Disclaimer:
This is my attempt to DIY.
I am not a mechanic.
Always seek an expert's opinion.
Пікірлер: 93
Informative video lalo na doon sa mga mahihilig sa mga machinery
Very good tutorial. Malaking tulong to sa mga taong gustong matuto ng ganyan.
Very helpful to everyone...thank you for that nice toturial and it's really appreciated...you do well properly...keep in touch see yah
salamat sa pag share at dagdag kaalaman na naman saken to. malaking tulong to sa sasakyan ko
hard working but i really appreciate that kind of work good job sir
thanks sa pag share ng video boss very informative unique ng sound
Nice content thanks for sharing this video! Malaking kaalaman sa mga gustong matuto ng pag kumpuni ng sarili sasakyan. Good job keep it up at God bless!
Wow, this diy thermostat replavement is very helpful. Thanks for sharing bro. Sending love and support to your home. See u!
wow ..this is nice..madami matututunan ..nice po
galing nyo naman mag ayos tuloy2x lang po sa ginagawa nyo
Watching you here ... thanks for the tutorial sir .. ganun pala ang pagpapalit medyo mahirap sa akin heheh . Am learning from you po . Godbless po
Helpful for all the riders.. See you around!!
its very helpful and informative, thank you for sharing
Thank you sir , actually my leak po yung i10 ko at doon pala nagmumula ang leak . Pacheck ko po uli .. godbless
@misterDIYzilla
3 жыл бұрын
Thanks and hope maayos po sya. Safe trip and driving!
Nice tutorial salamat s pagshare
Helpful ang iyong intek good at natuto tayo
nice and informative video..more videos to come boss..
very helpul vids.. keep on uploading,,,
Nice tutorial sir. Keep up po.
Thank you po for the information. God bless po.
Wow that's nice and good presentation
Good job thnx for sharing
This is helpful thanks for sharing see you around
Great content video..at least may idea na ganyan po pala magpalit ng thermostat..
@misterDIYzilla
4 жыл бұрын
nakabisita na rin, salamat!
@margauxlifePh
4 жыл бұрын
@@misterDIYzilla maraming salamat po sa pagmamahal
That is good and helpful tutorial though..Keep it up..
muchisimas gracias, me anime a arreglar mi automóvil gracias a tu tutorial. Mi auto quedo impecable.
@arseniobajaojr.9554
Жыл бұрын
San pwede makabili nung mga hyundai eon genuine parts?
@misterDIYzilla
11 ай бұрын
Hi po, if you are in Manila, I go to MRS Auto Hub c/o Roxanne Sapno, or Fronte Motor Parts. They sell genuine Hyundai Mobis parts
@arseniobajaojr.9554
11 ай бұрын
@@misterDIYzilla Thank you for the info.
New friend here. Informative blog Keep it up!
That's very interesting and informative.
@kingstonjensen5589
3 жыл бұрын
I know I'm quite randomly asking but do anybody know of a good website to stream newly released series online ?
@brixtonalijah2952
3 жыл бұрын
@Kingston Jensen try Flixzone. You can find it by googling =)
@vanmarley7807
3 жыл бұрын
@Brixton Alijah yup, have been watching on flixzone for years myself :)
@kingstonjensen5589
3 жыл бұрын
@Brixton Alijah Thanks, signed up and it seems like they got a lot of movies there :D I appreciate it !!
@brixtonalijah2952
3 жыл бұрын
@Kingston Jensen glad I could help xD
Ganito mga hanap kong tutorial ngayon. Gusto kong ako na mag PMS ng oto ko mahal sa casa eh. hehe
Wow very interesting po... See u po..
Great. Helpful content. Thank youfor sharing . See yoy
@misterDIYzilla
4 жыл бұрын
nakadalaw na, salamat!
How do I know if my coolant temperature sensor is bad?
Hello cute ng intro video keep safe Godbless
Salamat o sa pag jna sa bahay kom this TUTORIALS malaking bagay sa hubby ko. Salamat po
Thanks for sharing this. I'm here sending you a gift. Thanks for dropping by in my house
thanks for sharing.. new friend here ... keep in touch
New friend here . Enjoy watching. Stay connected.
Wow love the contents may nakuha nanaman me idea sayu lodi new sub hir from bicool.kaburaot is the call.
@misterDIYzilla
2 жыл бұрын
Salamat idol 😁😁
thanks to this
THANKS BRROOOOO
i like u video,,very kreative bigs support from new friend see u
En el tablero a que temperatura se debe activar el electroventilador o si lo pongo directo en que afecta
nice one po. thank you for this useful and informative video. keep it up po. #ayaay
Ang galing idol mat natutunan na namn ako.keep vlogging ayaaytibiag
@misterDIYzilla
4 жыл бұрын
nakadalaw rin sa wakas!!
Nice video idol ang GALING GALING talaga.ingat po at Godbless po.panice naman nang bahy ko idol salamat po .
@misterDIYzilla
4 жыл бұрын
nakabisita din sa wakas, salamat!
👍👍👍👍👍
Me podra decir dónde va la manguera que viene del filtro de aire para el cuerpo de aceleración
@misterDIYzilla
Жыл бұрын
Question is "Can you tell me where the hose that comes from the air filter to the throttle body goes?" As air flow passes the throttle body, the Electronic Control Module through its sensors work on the throttle position to control and provide the right amount of air pressure in the manifold
thanks for sharing, keep vlogging, #ayaay
@misterDIYzilla
3 жыл бұрын
..been awhile since I last checked, thanks, done visiting!
hi sir upon replacing your water outlet did u add some silicon gasket in your water outlet? or no need?
@misterDIYzilla
2 жыл бұрын
Hello, yes I still applied hi-temp silicone sealant, although the water outlet already has rubber insert
@mikhailsula9138
2 жыл бұрын
@@misterDIYzilla thank you so much! have a nice day
THANKS FOR SHARING YOUR VIDEOS.VERY INFORMATIVE.LEGIT FREIND FR AYAAY TI BIAG
Ayus friend. New friend here from. ayaay ti biag.😊😺 hope po bahay ko😊😺
@misterDIYzilla
4 жыл бұрын
hello new friend, coming up..
Thanks for sharing lods.New friend here. Here's my full package for you. Kaw na bhala magbalik lods😊
hello new friend here stay connected ayaay
mas idea palitan na din thermostat housing kasi plastic din yan at water hoses lalo na luma na sasakyan.
Thermostate temperature in degree
thanks for sharing. Idol ko trabaho mo. pls hugback
dapat ba na palitan din yung thermostat housing?
@misterDIYzilla
3 жыл бұрын
Hi sir, if wla pa signs of deterioration and thermostat lang ang prob, we may opt not to change it. Pero if may history of overheat na or if more than 2 years na yung water outlet, it would be best palitan na rin together with the thermostat. In my case, I bought the car as second hand, and just to be safe, I changed the water outlet na rin
Sir ano po ba problema nang eon kapag nawawala yung temp guage at the same time humihina yung lamig nang aircon? Bumabalik na man sya after ma off yung engine.
@misterDIYzilla
2 жыл бұрын
Hi sir based sa experience ko pag nag humihina yung lamig ng a/c, common possible reasons are either ha-high temperature yung engine, meaning malapit na sa overheating, or, madumi na yung a/c evaporator or other components ng a/c. Pero pag madumi na evaporator, usual symptoms is pag pinatay makina matutunaw yung build up ng yelo sa evaporator and you would notice maraming tubig yung nilalabas nya sa ilalim. Then after a while and started the engine, malamig ulit. Paulit ulit lang na malamig sa una then iinit, then pag pinahinga mo engine lalamig ulit. But then sir these were just my experience
DEMASIADAS TOMAS CERCANAS, PERO NUNCA SE VIO DONDE IBA COLOCADO EL TERMOSTADO, EN QUE AREA DEL MOTOR.
Good eve san kapo naka bili ng parts? thanks
@misterDIYzilla
2 жыл бұрын
In pampanga, there's Saroo's Auto Supply located along Friendship Highway. They also partnered with Lazada. Here's the link: s.lazada.com.ph/s.WEDgy. Elsewhere, one prominent supplier in Manila is M.R.S. Autohub through Roxanne Sapno, searchable in Facebook. They ship nationwide. Happy DiY-ing!
@mikhailsula9138
2 жыл бұрын
@@misterDIYzilla thank you so much
very helpful thanks for sharing done watching i hope you'll visit mine
@misterDIYzilla
3 жыл бұрын
..been awhile since I last checked, thanks, done visiting!
6:00 temostato
O
A1fX li
Ganon lang pala kadali mag replace ng thermostat water outlet at temp sensor madali lang
Plz Pali sukli Ng banana banana to banana done plZ return banana
@misterDIYzilla
4 жыл бұрын
papunta na kahopya