When making fuel from vegetable oil you should wash the fuel after extracting the glycerin. If You use too much sodium hydroxide the final product can have some dissolved NaOH in the liquid making it slightly basic which can slowly damage fuel lines an the engine.

@MrWeiserrr

7 ай бұрын

How do you “wash” the fuel ?

@brianmurphy8790

7 ай бұрын

I was gonna say just that. He never washed it!

@brianmurphy8790

7 ай бұрын

@@MrWeiserrr You literally 'wash' it in clean hot water. Then you wait for the oil/water to separate and then drain off the water. Finally you should dry the oil to remove any remaining moisture. You do that by adding calcium carbonate to the oil and leaving it a day or two.

@MrWeiserrr

7 ай бұрын

@@brianmurphy8790 cheers !! I genuinely thought that as he didn’t elaborate on the word “wash” !🤯! why is this not wide spread knowledge, I’m gonna have to start doing this & stock pile it for when SHTF. Nice pic btw I guess you could say I’m from the house of Lancashire 😉

@wake-archus

7 ай бұрын

@@MrWeiserrr this stuff will last about ten years at room temp. so you may be better off storing the base components instead and making the fuel as needed after shtf.

I have done this, made several hundred liters of Bio some years ago. I was driving a Toyota Prado KZTE engine. Few Problems: 1. Not as easy as you might think to collect the oil. Fast food shops have agreements already OR staff take it. 2. That cleaning / post production process is VERY important - the diesel will look clear but still has soap dissolved in it. 3. Be prepared to get Diesel Filter Warning light come on when you run it pure. ( I had to change my diesel filter) BUT the car ran just fine on it: Mixed 50/50 AND once I ran a full tank just home made Bio. I stopped making because I could not get enough oil to make it worthwhile.

@wyattnixonlloyd8570

2 ай бұрын

I agree- I run pure veggie oil in my car and even though its rewading its not easy, and the hardest part is getting hold of enough waste oil!

@CatDaddyx2

Ай бұрын

My dad owns a restaurant. I really need to take advantage of that it sounds like

@cameronmurie

Ай бұрын

@@CatDaddyx2 bio diesel in small ( say 50 liter) quantities is very doable, fun, and a cheap way to run a small older diesel motor. IF you can get regular veg. Oil supply. ( For free)

@CatDaddyx2

Ай бұрын

@@cameronmurie I got an old diesel kholer generator that I wouldn’t mind running on it

@GiorgiZhorzholiani22

Ай бұрын

Can I use baking soda, Sodium Hydrocarbonate (Na2CO3) instead of sodium hydroxide (NAOH)?

You normally "wash" with water the oil after filtering to remove rests of soap. To avoid creating foam, you should nebulize water above the oil. Water is more dense so it will travel downwards and settle on the bottom, taking the soap with it. To remove the water you just need to have a valve on the bottom and empty the tank until there is no more water. You do this as many times until you get clear water on the bottom.

Have you ever tried removing the soap with "water washing"?

Also you probably don't have the additives they use for Winterdiesel. And as you already stated: Without those the diesel gets too thick to properly flow when cold. Diesel gets pretty goey pretty fast. So in colder weather you might wanna use more Diesel from the gas station and less from you own production. Depending on how cold it gets where you live be careful about that.

@Just2Evil

7 ай бұрын

Adding 1/10 of kerosene to the mix will probably help.

@marcsduk

7 ай бұрын

⁠@@maxa.629kerosene is lighter than diesel and in uk it’s used as heating fuel

@gergosz3609

7 ай бұрын

do it like the old timers and put a bit of gasoline in it

@kaptain1477

7 ай бұрын

You can have two tanks. One for diesel and one for bio diesel. You start the car with diesel and reroute the heat into the bio then switch to Bio diesel.

@ebikecnx7239

7 ай бұрын

Just add kerosene and methanol, it's not rocket science.

if you are going to make alot of biodiesel and have large waste oil supply i really recommend to get centrifuge filter to make the filtering way easier and better

@anonimoqualquer5503

2 ай бұрын

I think a vaccum filter is better(cheaper, Easy to find)

Among the many other things I did with _Pisco sin Fronteras_ down in Pisco Peru, I ran the biodiesel rig for three months. I used 100% biodiesel in the volunteer truck which routinely pulled a heavy cement mixer, equipment and around twenty volunteers packed inside/outside. The centerpiece of our biodiesel rig was a converted hot water heater, the element inside provided the heat. External to this was a network of piping to move the product around and a number of valves to direct the flow. There was an inline filter and several large tanks for three rounds of filtering with bubbled air in each. Honestly, we just left the ethanol residue in the biodiesel which does no harm to the end product. As for the drained-off glycerin, this then was used to manufacture soap which we sold. We provided clean buckets to the local restaurants and once each week made a pickup of used cooking oil from them. I note that it doesn't get too cold down in Peru, to be honest. Be prepared to replace your car/truck's fuel filter once or twice after switching to biodiesel since the fuel is soapier (some glycerin) and will internally clean your engine as a result, the residue from your engine then potentially clogging that filter. I'll throw out there that this was an older-style diesel truck with glow plugs which I'd suggest would be optimal for this.

This process is usable only for older diesel engines, not for newer common rail / PD engines. I had old car (VW Golf 1,9 SDI from 1997 year) and it runs about 100 000km on home made bio diesel (FAME = Fatty acid methyl ester)

@TalRohan

7 ай бұрын

well said new engines with catylytic converters and partical filters don't do well either , not the engine but all the sensors will go scatty and basically make your car unusable, if you have a tdi with a german fuel pump and viton seals youre golden, you'll use more fuel filters but it works ..Diesel engines were originally designed to run on this stuff no mention of heating either for some reason....

@__alves_

7 ай бұрын

I have the same VW but 2003

@maximusboscus

6 ай бұрын

This is actually wrong. Biodiesel eats away the rubber seals on old cars because they are not prepared for it. New cars are actually prepared for it.

@TalRohan

6 ай бұрын

@@maximusboscus having tried to run newer vehicles on 100% biodiesel and seen what happens to for instance Lucas fuel pumps when in contact with biodiesel I can assure that there is nothing particularly wrong with the statement... All new diesel cars "should" be able to run with a small percentage of biodiesel because its already in the fuel but that doesnt mean they can run on it. In fact most new cars have so many sensors to reduce engine temperature and particulate filters that clog remove unburnt biofuels in stead of what theyre supposed to do that if you put even a meduim percentage of biofuel in a newer vehicle you will have an extremely expensive problem...fuel eating seals and fuel lines. pumps that clog up, filters that clog solid in the cold, exhaust gases that destroy the catalytic converter, and particulate filter. Manufacturers started out making cars that could run on biofuels and then redesigned them and gradually added peripherals that make it impossible for new engines to use even a half decent amount of biofuel.

@mintyfreshpavement

6 ай бұрын

I did basically the same process for my 2003 1.9 pd in my passat. OM642 CR diesel and my V10 tdi all for many thousands of miles

have you thought about using a dryer before putting this in your car? I have to say, you showed a much healthier respect for safety than many of the youtubers here, in North America!

I used to run straight cooking oil in my mk3 transit, bought 1 trolley full at a time in tesco! It worked out great until the autumn set in and the oil got cold so the van was difficult to start. I got round that real easily by going on holiday and coming back when it got warm again.

@mgrdigimarketing3035

6 ай бұрын

So rather than pumping it you bought your fuel in plastic containers which your country probably doesn't recycle 😂 nice work

@theravedaddy

6 ай бұрын

@@mgrdigimarketing3035 really? So ive just stored them in my loft, right? And while we are examinating your profoundly stupid reply.... tell me what country dispenses cooking oil in pumps.

@sasssquatch1467

5 ай бұрын

​@@mgrdigimarketing3035the best way to recycle plastic containers from cooking oil (as well as almost all other plastics) is to heat them in an oxygen free environment and distill the resulting vapors.. which makes diesel.

@Alex-mr4is

12 күн бұрын

@@sasssquatch1467which now is sold in some countries under the Name r99 or hvo 100 !

I’m kind of a casual prepper, so I love watching videos like this.

This is really interesting. All other sources made it sound incredibly complicated.

@DruggiePlays

7 ай бұрын

Yeah water and corn starch

@Mark-kc2ke

7 ай бұрын

maybe it should be complicated if you don't want your car's engine to fall apart?

You are way underrated sir! Shame on the people who watch all your videos but subscribe. Keep it up brother! 👍🏼

Hi there. The older generators can use the cooking oil just as it is. But there is a faster and easier way to make biodiesel for your car, heat up the oil and mix in a couple of packets of gelatin. It collects all the impurities. Then you can mix the biodiesel with 50% normal diesel.

@foty8679

7 ай бұрын

They will gunk up though, so its always better to put in the effort.

@tranquility382

7 ай бұрын

@foty8679 fair point. However, there is a patent on the gelatin method. It's significantly cheaper. The gelatin removes all the glycerin as well. It's a British patent. Once the gelatin has settled out, you mix 10% paraffin, and you are good to go. Obviously, you can add more paraffin if you want or a little gas station diesel. It's just a significantly easier and cheaper way to make the biodiesel.

Good use of the safety squint when using the grinder there!

looks very easy to do at home. thank you

great video Rulof. really like your style. titration at the beginning will improve the quality of the chemical conversion and washing at the end will clean-up the fuel ready for use

We in Brazil use vegetable oil which can be those that are discarded from restaurants, or new soybean oil we mix it with diesel directly and it works very well, however this mixture is almost entirely used by farmers in their agricultural machines and in transport trucks. It helps the environment and reduces fuel costs.

@keller_

6 ай бұрын

putting oil into diesel does the opposite of saving the environment, it only saves money, you oil produces a lot more smoke and toxic fumes than regular fuel, but hey as long as you save a buck right?

@henriquepawlak1930

6 ай бұрын

only in your head that pollutes more@@keller_

@williamsprout925

5 ай бұрын

​@@keller_shut up cuck.

Mi fa un gran piacere vedere che stai espandendo la community al resto del mondo. Keep it up bro!

I think this can also work well with ethanol. It's also cheaper because you can obtain high concentrations by pouring salt in vodka and the ethanol rises to the top of the solution. Obviously, the salt will need to be distilled out if used in an engine because it's corrosive but it's easier and faster to distill a solid from a liquid than a liquid from another liquid

@teasippingguy9316

7 ай бұрын

Well as far as I know Ethanol is 1) a lot cheaper than diesel so it's still probably more profitable to make diesel than to make Ethanol and 2) most engines can't run on Ethanol.

@atrumluminarium

7 ай бұрын

@@teasippingguy9316 you'll be running the engine on biodiesel tho not ethanol and if it's cheaper it will just make your biodiesel cheaper. Not sure what the purpose of your comment is tbh

@teasippingguy9316

7 ай бұрын

@@atrumluminarium nvm I thought you wanted to extract Ethanol and use that as fuel

@hantrio4327

7 ай бұрын

@@atrumluminarium But methanol is way cheaper than ethanol especially if not denatured

@atrumluminarium

7 ай бұрын

@@hantrio4327 But a lot of the methanol is obtained from natural gas so environmentally speaking it's still a fossil fuel source of carbon. Ethanol obtained by fermentation comes from carbon that was already in the atmosphere before so you won't be adding new carbon in.

I would highly recommend running it through a filter and fuel/water separater before putting in your vehicle

I have heard of using gelatin to remove the water and gliserol from the used cooking oil. It congeals like the run off of your Christmas roast when left in the refrigerator. Much cheaper process.

I love a good creative man ❤

Plain and Simple but process can be REFINED further. Thanks for a very good video, we appreciate a lot.

You can add a little bit of terpentine to the final mixture as it will greatly improve the viscosity of the biodiesel

Its best to pour all the oil into a large vessel and and wait for the sediment to settle to the bottom. Then open a tap, fitted a couple of cm from the bottom, to drain off the clean oil.

Muchas gracias por compartir con todos nosotros 💪😎🍿

You missed one important step is to remove water content in used vegetable oil by distilling it before using Sodium hydroxide and methanol and filtering it in final product and also important to adapt your car for the use of new fuel .

Means I can use it without adding some biodiesel from other gasoline station if im living in South east asia where the lowest temperature is at night around 20 degrees right?

And here in Australia if the government gets knowledge of you making your own fuel, (by law) they can put their hand out for the excise/tax (about 40c) per litre.

@challacustica9049

7 ай бұрын

Why?

@ebikecnx7239

7 ай бұрын

Nazis

@DavidMartin-ym2te

7 ай бұрын

In the UK it's OK to make it for your own use I think but if you sell it then the authorities will want their cut - and fuel tax in the UK is high so it's not appreciably cheaper than Diesel.@@challacustica9049

@mahbuddykeith1124

7 ай бұрын

That’s why you don’t tell anyone.

@starstencahl8985

6 ай бұрын

Given Diesel is 2US$/L where I’m from, that’s still a good deal

In Sweden, the maximum limit for Bio Diesel at most petrol stations is 7%. it is seen that many car manufacturers specify it as a maximum limit in their diesel engines, but the petrol companies also insert HVO in the diesel. Then someone in the USA said that biodiesel is not so good for the particle filter and of course also the diesel filter. There can also be problems with algae in the tank

Wow this is an impressive channel and especislly intro. Thanks brother.

This doesnt have to take so long if you heat the oil from the start. That will also take care of the impurities in the oil so you dont need a sieve for that. Your caustic and methanol ratios is also wrong,too little. This will cause your biodiesel to set in very cold conditions.

If you don't want to use any harsh chemicals it is technically possible to distill used veggie oil and get the glycerin out but it's much more expensive

@95rav

7 ай бұрын

BS. And hydroxide isn't as dangerous as he makes it out to be: it is common drain cleaner. Use the same precautions.

@Joakico

7 ай бұрын

@@95rav Actually methanol is probably worse than NaOH. Their flame is almost transparent, is volatile so you may accidentally breath it. And in contact with eyes their vapours can cause severe damage. I was kinda surprised how he reacted to NaOH ( as I expected) but he didn't say anything about methanol.

@Toukout44

6 ай бұрын

@@95ravYea just let a droplet of drain cleaner in your eye you'll see if it's not dangerous

@95rav

6 ай бұрын

@@Toukout44 I didn't say t wasn't dangerous, fuckwit.

In an emergency situation I once used 20 litres of vegetable oil straight from the shop in my 2010 Toyota and it ran perfectly fine. Got me home ok and I wasn’t stranded in the middle of nowhere. Since then I’ve owned diesel cars for their high tolerance of using cooking oil as fuel. 😅

Very nice video! Dont stop making videos

Un itaiano che compare nel mio feed "strictly no italians" Fantastico! Continua cosi, spero che spacchi internazionalmente. Te lo meriti

For quicker filtering, get a external oil filter housing and pump the oil through a micron filter. We used to do that with waste oil furnaces.

I run a Vw T4 2.5 tdi on 100% oil no matter whether engine- or vegetable oil I just used coffee filters and it runs perfect in summer.

@kasparsstraut2247

4 ай бұрын

What about winter time?

@orhelyemreallok1811

2 ай бұрын

🤣🤣

Used on my benzin car and it worked very well

Seems ideal for oil lamps and heaters.

@jennyhammack5614

9 ай бұрын

Yeah it’s pretty good to hear a house

@soulextracter

7 ай бұрын

@@jennyhammack5614 The question is: Does your house have anything interesting to tell you?

This is why i love the old VW and mercedes diesels. Just filter the oil properly, put it straight in with a third normaly diesel and its runs perfectly AND you neighbourhood smells like fries.

I wonder what your neighbours thought when they saw you with all this in your garage 😂

@Paul-gu2lv

6 ай бұрын

Meth lab😉🤣

Do not use it in a newer common rail diesel but for older pump types it works well.

@stefano806

7 ай бұрын

Io uso olio di semi vari su una Fiesta TDCi da anni e nessun problema

سأستعمل هذا الوقود في التدفئه شكرا لكم معلومات قيّمه 🇸🇾♥️

@user-wx9vn1nr6u

6 ай бұрын

وانا معك كمان 😂😂

@MohmedAleamy-rt6xs

2 ай бұрын

حبايب البي form Yemen ههه

you can also make it from plastic by heating plastic to a specific temperature in a sealed container.

Just a tip: compressed air is usually pretty dry, which will pull the methanol out of solution (methanol is even more volatile than ethanol). You should really mix it mechanically

Just Put the Salat oil in the Tank of an old Diesel Car. It will Work. But Not in a Common rail. It will Break your high pressure Pump. I did it with my old 190 D Mercedes more than 20 Years ago. It worked fine. At this time Diesel price has been raised. Salat oil from Supermarket was much cheaper. There we're also seperaten Tanks available which fitted into the spare tire Container in the Back. Start and Finish with normal Diesel with a switch. But after that they raised the price for Salat oil, those Bastards. The Car ran good. I built an extra heating Tube into the Diesel circle to keep it better flowing in Wintertime. But a 50:50 Mix with Diesel was Always better. I Loved the smell of a Grill Party, everytime I have got out of the Car. The examination of exaust Gases was allways better Then with normal Diesel.

@W.Binderei

7 ай бұрын

Gut gemacht !

We are living in the dystopian world our grandparents feared.

Also regarding that the viscocity lowers with the temperature sure but that isn't the most important factor. when it comes down to diesels, FAME and kerosene/kerosine you have something called CP and CFPP first is cloud point the temperature when you first start noticing the impurities/parafine fraction. and the second is the cold filter prop blocking tendency that is when there are enough impurities that causes the liquid to not actually flow anymore both are temperature and mixture depended

Bro is new level

I used biodiesel in a mk1 Berlingo for a few years, the engine always sounded better when running on it.

@CoreMaster111

7 ай бұрын

My friends VW T4 bus does not like diesel mixed with biodiesel.

How much salt and water is in there? Doesn't diesel need adaptive for the high pressure injection pumps?

Just wondering.... Do you know what the 'Pour/Gel/Cloud point of your Bio Diesel is? I have heard that it can vary on your source of the oil, then slightly on the process..... My cloud point seems to be close to 20 degrees Fahrenheit... and in my process... I (water) wash my Bio diesel, and then, I filter the oil after washing.... to make sure that I remove any thing left from the process

@whatever_12

10 ай бұрын

Look like you know your stuff.. Any online forum or resources you would recommend to learn more about this?

great video

for mixing instead of air you can use computer fan with one broken blade and attach it to vibrate outside the container...

Informasi yang bagus... terimakasih, salam dari Indonesia

Great guide. Wash it to remove acidity. Centrifuge it to remove impurities that the micron filter can't. Otherwise injectors are very expensive to service. It's possible to make a cheap centrifuge from a blender.

You could literally make a sign " dump your waste oil here" and you get diesel for life

You can literally pour cooking oil into a diesel car right of the shelf. Or clean it before using used cooking oil. Either way we use way less cooking oil than diesel and diesel in general is a huge polluter.

Хорошо получается, у нас все проще фильтруют и смешивают масло без всякой перегонки с бензином 1 к 3 и всё прекрасно работает, на больших двигателях от 2,5литра.)

The 0.25% NaOH is by weight or by volume?

You can, but in warm climates or during summer time. In winter you won't be able to power anything without adding heaters to the fuel tank and / or adding additives to the fuel

Nice. Do you frequently change the fuel filter of your fiat?

In Serbia, but golf mj2, put unfiltered oil with an disel 1:1, and wholaaaa you have bio disel, trust me it works :).

thank you

Good stuff

You can filter all of your oil in the same time with starch! They bind all the stuff togehter and after that you have clear oil.

Since the process takes a bit of time, I think you can decrease the amount of homemade in the car to protect it, like 20L from the g station and 5L homemade.

At 3:30 you write 0.25% of NaOH 20% CH3OH but you have 2 liters of methanol alcohol, 20% of 20 liters equal 4 liters.

recomend getting safety glasses rated for liquids. You're using particle protection only.

If you are running your vehicle on engine oil, cooking oil , biodiesel I have found it to be better to mix 70% oil (whatever kind) and 30% petroleum, with this mix I have even been able to start my vehicle in -5. unfiltered engine oil straight out of an engine ( the engine has oil filter) idles nice nice to less smoke after sitting for a while Older Diesel cars will run on almost anything flammable as long as you can get it started. Quick tip if you ever get stuck and you have spray deodorant on you, spray that straight in the air in take well turning the car over, it will most likely start even in the coldest of temps

0:33 it's glowing you could wind a coil or use water boiler around i would say 159L could be easily use here

Sick stop motion intro

Make the oil warm for filtration and decant each bottle first to let 99% of the oil run through very quickly and then pour the junk in last and let it drip out for 30 minutes. If you want to use it as fuel for your car I'd wash the oil with some water to get the water soluble sh*t out of the oil. Some salt can be carried on with the oil. Why is the methanol yellow?

Can you use crude oil to get deisel without pyrolisys

Does the fiat 500 run on biodiesel ? How abot the dpf ?

جزاك الله خيراً ....تبدو طيب القلب ❤

👍 nice idea

if you got a cummins just put the oil straight in in with a bit of regular diesel roughly 80/20 mix and it should cherp it down np

اعلم اني دخيل . بس هل زيت زيتون يمكن انتاج بيو ديزل

Put oil in big container. Warm oil to 40° C and let all particles settle. Turn off heat allow oil to congeal into solid mass. Scoop out particles

I appreciate that the end of the video looked like a 1980s documentary lol

Can I use Ethanol instead of water and as I see you can wash the soap out with water so is it okay to already use a 70% Ethanol 30% water mix from the beginning?

@Humbulla93

7 ай бұрын

you can use ethanol but you´d have to have 100% ethanol which you can get by putting dry calcium chloride or epsom salt into 96% everclear, then react it with sodium hydroxide. being that ethanol is one carbon chain longer it will make the biodiesel a bit more viscous, so it would be better to make a 60:40 mix 40 being biodiesel. the more water you have in the reaction the more soap you´ll get which lowers yield and takes a bit more effort to take out, which should be done anyway, by spraying water into the biodiesel and then let it separate and either decant it or use a pipette to suck it up, afterwards you have to dry the biodiesel with dry calcium chloride. you can get by putting the salts into an oven and bake for some time, after that crush it to a powder and store it airtight with no humidity or use right away

is this kind of fuel is good for common rail or newer engines?

I use an oil pump with 2 filters filtering down to 5 micro meters attached to pump it in the tank. This way there are no stains whatsoever.

Thanks

WIth the cost of the extra chemicals needed is it still worthwhile? Where I am it seems that there is no savings.

Are they safe for let's say a Diesel Power Generator ?

Does regular diesel mix with vegetable oil? Can they be mixed in 50-50 proportions or do they not mix together?

Merci.

If you warm the oil in a pot to 54⁰ C and then mic it with the chemical and stirr it with an electric long arm wisk like the one the painters use...in less than 10 minutes it would split.

Hy, before I used the oil directly in the car with 50%. Sure you have to make a filtration, and it is better in summer time, because with the cold temperature, the oil become thicker. Kris

is this cheaper or more expensive than regular diesel from the fuel station?

methanol is the best for this reaction but you can use ethanol too if its cheaper, here in the US its sometimes easier to get 99% ethanol not for human consumption

Fine spray of water to stop reaction

You need to take an aliquot of the initial iot and titrate it for free fratty acid, and THEN you can determine how much methoxide you need to generate - how much hydroxide to use.

Very interesting, I used to know someone who made his own diesel and put some in my car, it failed the MOT on emissions as I forgot that I had that diesel in the tank lol, took it back a week later with bought diesel and it passed ok, My mate said if I'd told him it was going for MOT he would have added some more methanol to the mix iirc.

Sodium hydroxide is really not as dangerous as you think. Its reaction with the water in your methanol can be made much worse by the flask you used if boiling occurred. Your choice of container actually made it more dangerous than it otherwise would have been. The most dangerous part of handling it is when it is in a concentrated solution, and when that solution is hot.

произношение топ! я со своим средним английским понял всё) лайк!