EGR ( air injection ) valve 1.8T Audi A6 Cleaning / Replacement C5 - P0401
Here is a Playlist with all the videos I made about this car :
• Make Your Car Run Bett...
A clogged EGR valve will give you a rough start and the engine will run rich in fuel at least at the beginning . So inspecting it and cleaning it / replacing it should be done in order to fix the issue. On this car the dirt and carbon build-up was so bad , that even after the EGR valve was submerged in gasoline it still did not open properly when tested with the vacuum hand pump .
Disclaimer :
This youtube channel: "doit_vehicles " can not guarantee that this information suits your car . "doit_vehicles " assumes no liability for property damage or injury incurred as a result of any of the information contained in this video. Use this information at your own risk .
#doitvehicles
Пікірлер: 32
A6 All the AIR sesors Video : kzread.info/dash/bejne/Y3iMzbl7e8LIeZM.html
I just want to say, your videos on the 1.8t have been invaluable while i help my sister rebuild her first car. Great shots, high quality and you barely skip anything. Keep at it!
@doit_vehicles
2 жыл бұрын
I am happy to hear that !
This was the most helpful combi valve replacement how-to video I have watched, partly because of your exposition and partly because the wiring and piping most closely matched those of my 2001 Passat (AUG engine). Instead of removing the air injection inlet hose completely, I removed the three mounting screws from the valve adapter itself, swung the assembly upward, and pulled off the combi valve assembly. I have the Schwaben low-profile Torx driver set, and wish I had a hex version of it, but a T30 fits a 5mm hex decently enough, assuming the bolt is not too tight. Anyway, everything went according to plan. I cleaned the small amount of carbon off of the adapter, replaced the gunked-up valve, and reassembled everything. Thanks again for a very helpful video!
I've got a 04' Passat GL 1.8T Wagon with 5-Speed Manual & Four Motion. Last of this specified vehicle according to VW's chart of registered vehicles. She runs still smooth and quiet but she has 228k. Still has alot of it's original one time use clamps and tubes (Sept PCV of course). Appreciate the video. I'm sure she is due for a EGR cleaning. Thanks much for the video.
I have a simple Audi A6 1.8T 2002, and got the "Secondary Air Injection System Incorrect Flow P0411" Error. Should I replace thr EGR with a new one in order to solve the issue?
sall, before you take the egr out and clean the car, it had some symptoms, the engine was misfiring, etc
Gracias por todo
@doit_vehicles
3 жыл бұрын
de nada
How to check the solenoid under intake that kontroll egr valve?
Hi i have problems with audi a6 1.8t very noisy around the egr valves after heating the engine.tank you.
@johne6081
Жыл бұрын
Check your hydraulic cam chain tension adjuster. If that is the source of the noise, you need to tend to it before the chain jumps a tooth or two and you mash your 12 inlet valves against the pistons. (Big OUCH financially.)
Abim bende 200 model var a6 18 turbo aracta cekiş düşüklüğü var bide silkeleme oluyor otomatik vites
Ustam eline sağlık on numara cekim bende a6 18 var yag ışığı ötüyor hep bide aracta silkeleme var yardımcı olursanız sevinirim ustam
@karaca100
2 жыл бұрын
Yağ ışığı derken stop mu yazıyor? Yağ çekme hortumu var karterde o tıkanmıştır
You sure this is called EGR valve ? This is COMBI VALVE and it doesnt take the exhaust but air from SAI pump. Check again.
@doit_vehicles
3 жыл бұрын
true , but a lot of people are looking for it as a EGR valve
@iMercury989
3 жыл бұрын
So where is than egr valve? Ziko, ako je ovo combi valve ima li egr-a?
@ishe728
3 жыл бұрын
My Lord it doesn't matter what it is called, it still needs replaced and this video shows you how to do it. Combi is actually what the Germans call the EGR valve, so that's technically not correct either, if we are using your definition.
@PuddlePuf
3 жыл бұрын
@@iMercury989 kao ja znam, nema.
@goranmarinkovic6336
3 жыл бұрын
@@PuddlePuf kapiram. Zamenio sam ovaj ventil, auto mirnije radi, bolje vuce, nasao sam polovan za 20e.
Jakie byly objawy ?
I delete Kombi valve lol