I've had so much trouble with DPFs I got myself a small diesel with only an EGR valve to worry about. I swear I have DPF PTSD from dealing with the last few Renaults my wife had.

Nightmare having to tell a customer he needs a new DPF after two weeks ownership

The videos baz does are amazing 👍

Good vids Baz. Been watching you and Jimmy trying to understand what's wrong with my 2018 single turbo Vivaro. It's doing a regeneration every 20 miles. Just don't know what it's being caused by. Local diesel specialist garage has checked for leaks, pressure tested, check for codes etc. Nothing obvious. Jimmy thought the DPF looked ok after he cleaned it/checked over some electrical faults and I sent him some data once everything had cooled down the next morning. So I wonder if it's a engine soot issue, software bug or some crappy hardware. No fault codes other than the one dilution one that shows up after 3000 miles. Whatever it is, it's bloody frustrating and I do wonder if there's a core issue on these vans where something like what I'm experiencing is causing all sorts of havoc and it's not being dealt with. The typical pressure sensor pipe being blocked is well documented but some of these other issues don't seem to be. Maybe they just aren't as common. After speaking to Jimmy and a local diesel specialist they both seem to say they have an awful lot of 2018 onwards, coming in. Have you seen any of these vans with repeated oil dilution fault issues from too many regenerations? Just back to the vid quickly, have they literally just sprayed it silver to hide that it's gone rusty, or what? Thanks, PWU.

Does the customer have a warranty of any kind on this vehicle? In the states, the dealer that sells the car usually gives the buyer at least 30 day warranty on a car this new. Even if the car was a private party sale and doesn't a dealer warranty, there is a government mandated 8 year, 80K mile warranty on emissions components through the manufacturer.

If DPF regens weren't working properly you'd expect oil level to go high as it dumps fuel there before the regen is complete. Are the turbo seals knacked? Ni point replacing DPF if it will clog again because of this - easy way to tell is look at the boost pressure sensor, if its caked you can investigate further. I would also check for fuel contamination; tends to be the first thing that sets off this chain of events.

Just rip it off, map it out and send it

Hi mate, What should the differential pressures be on these 1.6 at idle and 3k rpm?

Is it ging to be fixed ? Ore did the customer bought another one 😮

so many crooks out there great video Baz

@bazmeredith

4 ай бұрын

Cheers buddy

DPF replacements in the past were not that expensive have they quadrupled in price like everything else?

DPF issues are a nightmare baz i got rid of my 2015 mazda cx5 2.2d as i had dpf issues and in the end it wasnt worth it ....there is a irish guy on here to sorts lots of DPF issues -he uses launch products aswell if you know of him or watched him at work?

@bazmeredith

4 ай бұрын

I know Jimmy very well we talk all the time his knowledge on dpfs is 2nd to none 👌👌👌

@MX5MAN4

4 ай бұрын

ahhh yes jimmy and thats good as his knowledge with DPFs is 2nd to none @@bazmeredith

@eoghanhennessy443

4 ай бұрын

The reason them mazda 2.2d have dpf issues is because the exhaust cam shaft is burnt out lobes worn. keeps the cyclinder constantly rich .mazda sell an upgraded cam shaft if u dont fix them the valves start sticking and blown head gasket will follow

@MX5MAN4

4 ай бұрын

ahhh ok thanks mate im glad i got rid of it before it did have major issues then @@eoghanhennessy443

That oil has gone somewhere ,

💪💪💪

We have had these engine in blowing oil in on the cold side of the turbo bearing was fine just seals had failed the funny nuts on the small plastic piece on thr turbo if you remove can some time see it when you run the engine . Is there not a crowed up your way that professionally clean them

@bazmeredith

4 ай бұрын

It's already been done by the looks of the dpf hence why it's painted silver

@eoghanhennessy443

4 ай бұрын

We had chancers in scrap yards painting them silver selling as recondition. The fact the oil is gone low even with a new one could still be happening

Baz - what’s the scanner you’re using? Looks like the business!

@bazmeredith

4 ай бұрын

It's launch euro tab 3 buddy 🤙

@D1ARBO

4 ай бұрын

Thanks Baz!

Grabber=total recall nose bug puller

@hunchanchoc8418

3 ай бұрын

Get your ass to Mars!

First here!